Академический Документы
Профессиональный Документы
Культура Документы
481
SD-516 1998 SECTION V SD-516
482
SD-516 ARTICLE 24 LIQUID PENETRANT STANDARDS SD-516
11.4 While the solution is being stirred, add a 6.9 0.7 0.5
20.2 2.2 1.8
measured spoonful of BaCl2 crystals (0.3 g) and begin 63.3 4.5 1.6
timing immediately. A The test method is linear to 40 mg/L. Testing at the 63.9 level was
11.5 Stir exactly 1.0 min at constant speed. accomplished through dilution as described in 11.2.
483
SD-516 1998 SECTION V SD-516
TABLE 3 TABLE 4
DETERMINATION OF BIASA MEAN SULFATE RECOVERY AGAINST
CONCENTRATION ADDED WITH OVERALL STANDARD
Statistically DIVISION SHOWN FOR INTERLABORATORY
Amount Amount Significant EXPERIMENTAL RECOVERY OF SULFATE FROM
Added, Found, at 5% Level REAGENT WATER AND DRINKING, GROUND, AND
mg/L mg/L 6Bias 6%Bias (at 6 0.05) SURFACE WATERA
Reagent water 20.8 20.4 0.4 1.9% No
63.9A 63.7A 0.2 0.2% No Mean Surface Recovery (X), mg/L
Sufate
7.0 6.6 0.4 5.3% No
Added, mg/L Reagent Water (ST) Matrix Water (SO)
Drinking, ground
and surface 7.0 6.6 (0.5) 6.9 (0.7)
water 20.8 20.2 0.6 2.7% No 20.8 20.4 (1.0) 20.2 (2.2)
63.9A 63.3A 0.6 0.9% No 63.9 63.7 (2.5) 63.3 (4.5)
7.0 6.9 0.1 1.8% No A The test method is linear to 40 mg/L. Testing at the 63.9 level was
A The test method is linear to 40 mg/L. Testing at the 63.9 level was accomplished through dilution as described in 11.2.
accomplished through dilution as described in 11.2.
14. Keywords
13.3.2 These collaborative test data were obtained
on reagent grade water and natural waters. For other 14.1 drinking water; ground water; sulfate; surface
matrices, these data may not apply. water; turbidimetric
APPENDIX
(Nonmandatory Information)
X1.1.2 This test method covers the determination X1.2.2 This test method covers the determination
of sulfate in water and wastewater. Samples containing of sulfate in industrial water. Samples containing from
from 20 to 100 mg/L sulfate may be analyzed. 5 to 1000 mg/L of sulfate may be analyzed.
X1.1.3 Sulfate is precipitated and weighted as X1.2.3 Sulfate is titrated in an alcoholic solution
barium sulfate after removal of silica and other insoluble under controlled acid conditions with a standard barium
matter. chloride solution using thorin as the indicator.
X1.1.4 This test method was discontinued because X1.2.4 This test method was discontinued because
there were insufficient laboratories interested in partici- there were insufficient laboratories interested in partici-
pating in another collaborative study to obtain the pating in another collaborative study to obtain the
necessary precision and bias as required by Practice necessary precision and bias as required by Practice
D 2777. D 2777.
484