Академический Документы
Профессиональный Документы
Культура Документы
Plastics
Version: 09/01/2015
General Summary
More Facts
1. Nature, history and prevalence of plastics
2. Transmission to the environment, plants, animals and humans
3. Diagnose of poisoning
4. Potential hazards and adverse effects
5. Severity of the hazard
6. Standards
7. Analysis methods
8. Control measures
9. References
10. Websites
APPENDIX / APPENDICES
Name: Plastics
code: F01
Severity: medium
The control measures specified in this fact sheet are all control measures which can be used depending on the
product and/or process step.
F1 Plastics - Feed materials for delivery to cattle farms, and - 1.5 g/kg (dry GMP+ Via manual separation Microscopic
matter basis) and weighing determination in
accordance with
See GMP+ BA 3: the instructions of
Negative list the laboratory.
- Wet mixes for delivery to livestock farmers This norm was included
subject to the outcome of
the discussion taking
place in the European
Commission.
[1 ] Action limit: A feasible limit agreed in consultation with the sector, supplier or customer. If this limit is exceeded then an investigation into the cause should be undertaken and corrective measures should be
taken to remove or control that cause. Maximum levels in mg/kg (ppm) of the feed materials or compound feeds, derived to a moisture content of 12% unless mentioned differently.
Rejection limit: A feasible limit agreed in consultation with the sector, supplier or customer. If this limit is exceeded then the product is not suitable for use as feed material or animal feed. Maximum levels in mg/kg
(ppm) of the feed materials or compound feeds, derived to a moisture content of 12% unless mentioned differently.