Академический Документы
Профессиональный Документы
Культура Документы
1..EMF induced in a coil rotating in a uniform magnetic field will be maximum when the
a) flux linking with the coil is maximum [ ]
b) rate of change of flux linkage is minimum
c) rate of change of flux linkage is maximum
d) rate of cutting flux by the coil sides is minimum
2.The d.c. armature winding in which coil sides are a pole pitch apart is called ............
winding.
(a) multiplex (b) fractional-pitch (c) full-pitch (d) pole-pitch [ ]
3.In small DC machines, armature slots are sometimes not made axial but are skewed, results
a)quiter operation b)slight decrease in losses c)saving of copper d)both a & b [ ]
4.A 4-pole, 12-slot lap-wound d.c. armature has two coil-sides/slot. Assuming single turn
coils and progressive winding, the back pitch would be [ ]
(a) 5 (b) 7 (c) 3 (d) 6
5. Lap winding is suitable for ............ current, ............ voltage d.c. generators. [ ]
(a) high, low (b) low, high (c) low, low (d) high, high
6.The critical resistance of the d.c. generator is the resistance of [ ]
(a) armature (b) field (c) load (d) brushes
7.In a d.c. generator, the generated e.m.f. is directly proportional to the [ ]
(a) field current (b) pole flux (c) number of armature parallel paths
(d) number of dummy coils
8..In a dc machine ,the armature reaction and the inductance of commutating coils results in
a)over commutation b)under commutation [ ]
c)linear commutation d)sinusoidal commutation
9. If the applied voltage to dc machine is 230V, then back emf for max power
developed is [ ]
a)200V b) 230V c) 115V d) 460V