Академический Документы
Профессиональный Документы
Культура Документы
ELECTRONIC SCIENCE
Paper II
Time Allowed : 75 Minutes] [Maximum Marks : 100
Note : This Paper contains Fifty (50) multiple choice questions, each question
carrying Two (2) marks. Attempt All questions.
1 [P.T.O.
AUG-38211/II
(A) UV Lithography
s
(B)
s 2
2
for : impedance ?
R = 5
(A) linear circuits 1 2+
2
AUG-38211/II
9. How is z 22 related to
11. In a bridge rectifier the secondary
h-parameters ?
voltage is 100 V, what should be the
(A) z22 = h22
minimum PIV for each diode ?
1
(B) z22 = h
22
(A) 100 V
h21
(C) z22 = h
22
(B) 141.4 V
h21
(D) z22 = h
22 (C) 200 V
J2 (A) 40
(B) 32
(A) low pass
3 [P.T.O.
AUG-38211/II
is :
(C) hie + (1 + hfe)RE
(A) Low power, high device density
(D) (1 + hfe)RE
(B) High speed, high device density
will be :
(A) rectangular wave
(A) zero
(B) triangular wave
(B) AB
(C) rectified sine wave
(C) 1
4
AUG-38211/II
implemented using :
when :
(A) 8 comparators
(A) EN = 0
(B) 16 comparators
(B) EN = 1
(C) 64 comparators
addressing in 8086 is :
19. A 64 kB memory device will
(A) AX
have :
(B) BX
(A) 16 address lines and 8 data
(C) CX
lines
(D) DX
lines is called :
5 [P.T.O.
AUG-38211/II
23. Which of the following I/O device 25. Preferred protocol for long distance
communication is :
provides memory and I/O compatible
(A) parallel
signal ?
(B) serial
(A) 8255
(C) error handling
by 15 % !\n);
(C) 09H
(D) printf(\ My salary was
(D) 04H
increased by 15%% ! \n);
6
AUG-38211/II
27. int X = 2 * 3 + 4 * 5;
29. Which of the following is the correct
What value will X contain in the
way of declaring a float pointer ?
sample code above ?
(B) 26
(B) float * ptr;
(C) 46
(C) * float ptr;
(D) 70
C ?
array
array
(D) C=getchar( );
7 [P.T.O.
AUG-38211/II
(A) 500
(C)
(B) 700
(D)
(C) 900
8
AUG-38211/II
multiplexed in a TDM-PCM
incident on a conducting surface, the
telephone system and the signals
magnetic field at the interface is :
are sampled at 8 kHz rate. Then
will be :
(B) same as in the incident
9 [P.T.O.
AUG-38211/II
limitation of transmitter
(C) negative resistance
(D) to ensure that the applied d.c.
rs (B) 0.33
10
AUG-38211/II
linear ?
(A) 1st
(A) a thermistor
meter
(C) 3rd
(C) p-n junction sensor
(D) 4th quadrant
(D) pyroelectric sensor
11 [P.T.O.
AUG-38211/II
47. How many significant figures are 49. A system is said to be stable if and
only if :
present in the number 10,450 ?
s-plane
(C) five
48. Which of the following equipments (D) some poles lie on the right half
(C) non-linear
(D) Scanning Electron Microscope
(D) Sluggish
12
AUG-38211/II
ROUGH WORK
13 [P.T.O.
AUG-38211/II
ROUGH WORK
14