Академический Документы
Профессиональный Документы
Культура Документы
REQUIREMENTS SECTION
The Division conducted an inspection on the attraction named Motor Cycle Jump in the city of
Hesperia, CA.
At the time of the Divisions inspection, the following items were reviewed:
Operating Guidelines
First Aid Report
Inspection of Motorcycles
Maintenance Documentation
Operation Documentation
Training Documentation
During the Divisions inspection, the Division noticed that motorcycle #5 had a broken roll pin at the
spindle end of the sweep where the motorcycle slides onto the spindles. The Division also noticed
that the front stop bar was not completely there. The portion that was missing went under the
motorcycle to prevent it from tilting forward to the point of rolling over. (At the time of the incident, the
motorcycle rolled forward and the injured party fell off the motorcycle.) This front stop bar has been
partially missing for some time.
The Division called the patrons mother on March 9, 2010 to obtain an account of this incident and
received a response on March 9, 2010.
This was the first ride her daughter rode on for the day. Another boy rode on the same bike she was
on before her. On the first round, the ride experienced no problems. On the second round, the back of
the bike lifted up. When the bike flipped up, she hit her head and her arm became caught. She was
dragged approximately 1-2 feet. She was transported to the Desert Valley Medical Center in
Victorville, CA. Upon evaluation, a one inch bump on the left side on the top of her head was
discovered on the hairline. There were no x-rays taken at the time and she was released from the
hospital. Her mother also reported that her daughters arm is sore with no bruising and is otherwise
doing well.
At the conclusion of the Divisions inspection, the following requirements were given to the
Owner/Operator:
R1) The Owner/Operator shall install a new roll pin and replace the missing front stop bar on
motorcycle #5. 3911(b)(3)
NOTE: This requirement has been complied with prior to the Division leaving the location.
R2) The Owner/Operator shall update the daily inspection and training to include the connection
points from the motorcycle to spindle / sweep. 7916
NOTE: This requirement has been complied with prior to the Division leaving the location.
R3) The Owner/Operator shall retrain the maintenance personnel on the updated daily inspection
checklist. 7916
NOTE: This requirement has been complied with prior to the Division leaving the location.
R4) The Owner/Operator shall inspect all motorcycle roll pins at the spindle end of the sweep.
3911(b)(3)
NOTE: This requirement has been complied with prior to the Division leaving the location.
Inversion Class 3
MANUFACTURE NAME TRADE NAME
KMG Inversion
Permit Number Tag Validation
A40246
Billing Information
Fee Type Insp Date Start Time Finish Time Elapsed Time Amount Billed
Inspection 05/26/2016 14:45 17:00 2.25 $375.00
Total 2.25 $375.00
REQUIREMENTS SECTION
Notification in writing that each of the listed items have been complied with shall be provided to the Division by the required
due date. Please send all written correspondence to the address listed above.
Cal Expo California State Fair Grounds Karla Kinsel (503) 643-6610
ADDRESS CITY ZIP
SDC Himalaya
Permit Number Tag Validation
A40323
Billing Information
Fee Type Insp Date Start Time Finish Time Elapsed Time Amount Billed
Inspection 07/07/2016 14:00 15:00 1.0 $125.00
Inspection 07/11/2016 13:30 14:00 0.50 $125.00
Inspection 09/01/2016 13:30 16:30 3.0 $375.00
Total 4.5 $625.00
REQUIREMENTS SECTION
Notification in writing that each of the listed items have been complied with shall be provided to the Division by the required
due date. Please send all written correspondence to the address listed above.
As a result of the investigation the following requirements were issued to the Owner/Operator:
R01) The signage posted at the entrance to the ride only restricts patrons from bringing backpacks and cell phones on the
ride. The Owner/Operator shall update the signage on this attraction to forbid all carryon items on this ride. 3910(b)
R02) The operators stated that they have an understanding of the carry-on policy for this ride, but there is no training
documentation to support this policy. The Owner/Operator shall update the operator training document to include the
carry-on policy. All operators and attendants positioned at this ride shall be retained on this policy. This training shall
be documented as required by ASTM F770-06. 7916(a)
COMMENTS/NOTES