Академический Документы
Профессиональный Документы
Культура Документы
Manual mode
Manu / Auto Signal:
- M / A, Manual / Automatic
1/ Manual mode:
2/ Automatic mode:
In this mode, the full control of Elevator simulator PM is under S7-PLCSIM. Automatic mode
Elevator Car, Doors, Call and Destination R. and Digit and Arrow
CL0A CL0B CL0C CL1A CL1B CL1C CL2A CL2B CL2C CL3A CL3B CL3C CL4A Elevator Car Position
1 0 0 0 0 0 0 0 0 0 0 0 0 Level (floor) 0 position A
0 1 0 0 0 0 0 0 0 0 0 0 0 Level (floor) 0 position B
0 0 1 0 0 0 0 0 0 0 0 0 0 Level (floor) 0 position C
0 0 0 1 0 0 0 0 0 0 0 0 0 Level (floor) 1 position A
0 0 0 0 1 0 0 0 0 0 0 0 0 Level (floor) 1 position B
0 0 0 0 0 1 0 0 0 0 0 0 0 Level (floor) 1 position C
0 0 0 0 0 0 1 0 0 0 0 0 0 Level (floor) 2 position A
0 0 0 0 0 0 0 1 0 0 0 0 0 Level (floor) 2 position B
0 0 0 0 0 0 0 0 1 0 0 0 0 Level (floor) 2 position C
0 0 0 0 0 0 0 0 0 1 0 0 0 Level (floor) 3 position A
0 0 0 0 0 0 0 0 0 0 1 0 0 Level (floor) 3 position B
0 0 0 0 0 0 0 0 0 0 0 1 0 Level (floor) 3 position C
0 0 0 0 0 0 0 0 0 0 0 0 1 Level (floor) 4 position A
NOTICE:
Position A sensor at each level indicates that the car is exactly leveled to the corresponding floor.
Position B sensor is used to signal that position A is approaching when the car is traveling downwards.
Position C sensor is used to signal that position A is approaching when the car is travelling upwards.
Position B and C sensors are then usefull to decrease the motor speed before stopping.
The floor and car doors are then driven by six S7-PLCSIM output signals:
CD O Car Door
0 Is not opened
1 Is opened
CD C Car Door
0 Is not closed
1 Is closed
- Call R. signals
- Destination R. signals
- Call signals
- Destination signals
call signals to notify that the pushbutton pressed to call the car is received
So, the indicators related to the Call R. and Destination R. signals are lighted ON / OFF thru S7-PLCSIM.
These indicators are located on the front view and inside the car respectively.
NOTICE: Call and Destination pushbuttons are temporary switches, i.e. they go ON when pressed then OFF when released. The signal generated is a narrow pulse.
On the top of each floor door and inside the car a dual display is available to announce:
The Digit and Arrow Display is then driven by six S7-PLCSIM output signals :