Академический Документы
Профессиональный Документы
Культура Документы
Quantity____________________________________
C.S.I. Section 11400
FD3/50FD3/75FD3/125
701 S Ridge Avenue, Troy, OH 45374
1-888-4HOBART www.hobartcorp.com
FOODWASTE DISPOSERS
ACCESSORY GROUPS GROUP E (For use with short upper FLOW CONTROL
housing only.)
GROUP A (For use with long upper Part No.
housing only.) NOTE: For use with short
Upper Housing Foodwaste 5 Gallons per minute for
Vinyl Scrapping Disposer only. Model FD3/50 through
Ring FD3/125 34" N.P.T................ 201721
Cover Stopper and Sink
Adapter Assembly for
CONE COVER
Stainless Steel 312" to 4" Sink Opening STAINLESS STEEL
Silver-Saver Sleeve
with Side Feed
Hole
VACUUM BREAKERS
Chrome Plated
Vacuum Breaker
3
4"................................................ 277112
Sink 16" x 20" x 7" (7" opening)
w/hole for water inlet.............204015-2 PRE-RINSE SPRAYS
PR-3 Heavy-duty
WATER INLETS Flexible Pre-Rinse
Spray (38" high
with wall bracket)
Cone Water Swirl Inlet ML-32333
1
2" N.P.T................................... 204380
ELECTRICAL CONTROL GROUPS Listed by Underwriters Laboratories Inc., for use with FD3 Disposers
(50 Hz. Electrical Specifications not submitted for UL Listing. )
Approximate
Shipping Wt. 19 lbs.
Approximate
Shipping Wt. 20 lbs.
Approximate
Shipping Wt. 11 lbs.
SAMPLE SPECIFICATION
Model H.P. Ph. Hz. Volts Rated Amps
1 60 120/208-240 9.2/4.2-4.6 FD3/75 B 4 (230/60/3)
FD3/50 1
2
3 60 208-240/480 1.8-2.0/1.0
1 60 120/208-240 10.8/5.3-5.4
Electrical Specifications
FD3/75 3
4
3 60 208-240/480 2.6-3.0/1.5 Electrical Control Group
1 60 120/208-240 14.8/7.7-7.4
FD3/125 114 Accessory Group
3 60 208-240/480 4.2-4.0/2.0
1 50 110-120/220-240
Contact Model Number
FD3/50 1
2
3 50 220-240/380-415 Customer Cut hole 19" for 18" cone. Hole to be 16" for 15" cone.
1 50 110-120/220-240 Service Solenoid must be installed in upright position.
FD3/75 3
4 For
3 50 220-240/380-415 Disposer may be easily rotated for better drain line connection.
1 50 110-120/220-240 Amperage
Center line at wall outlet of trap should not be higher than center line
FD3/125 1 4
1
Data of disposer discharge opening.
3 50 220-240/380-415
The dash (-) between voltages represents the range (low-high) of voltage operation. The If water pressure is in excess of 60 P.S.I. install a pressure
slant (/) line indicates the dual voltage operation accomplished by motor lead connection: reducing valve.
follow connecting diagram on motor. (50 Hz. models not submitted for UL Listing.)
As continued product improvement is a policy of Hobart, specifications are subject to change without notice.