Академический Документы
Профессиональный Документы
Культура Документы
b813 f62a14c1ed7
https://www.scribd.com/document/147569852/CES-Wrong-Answer-Summary-e6f376d5-321d-4a5b-
b813-f62a14c1ed7
Page 1/6
All designated SAR aircraft and civil aircraft carry equipment operating on the international aeronautical
distress frequencies (amplitude modulation). The aeronautical distress frequencies are?127.8 MHz
and/or 349.6 MHz
You are onboard a vessel enroute off the West African coast. How far off the coast do you have to be, to
be able to dump a mixture of food waste, glass bottles and floating packing materials ?12 nautical miles
off the coast
If all indications are that a cargo has been received without damages, irregularities or short shipment
and the phrase "apparent good order and condition" is entered on the Bill of Lading, what type of Bill is
this said to be? An endorsed Bill of Lading.
When a Master takes the leadership in approaching a problem, Must his first action be a decision that
will directly solve the problem?Yes, with his experience, it is most likely that he has the best solution.
Not necessary, he shall use all available resources. He should resist the temptation to step in and do it all
by himself
Page 2/6
In a distress situation, how many times or for how long should the emergency alarm signal be
sounded?3 times
Until all crew members and passengers have reported to their respective muster stations
After confirmation that there is no other radio-traffic, we call on a VHF working channel of a coast-
station. When you dont get any reply:You must wait 5 minutes before repeating the call
When a satellite receives a distress alert from a Cospas-Sarsat EPIRB, the relay of the distress alert
can be delayed because the satellite cannot immediately contact a:LES before the satellite is actually
seen by this ground station
When a character in the NAVTEX message sent is not received in the proper way: Any other character
will be printed
A lead battery of 200 Ah, in accordance with the DIN-standard, must be able to supply:1 ampere during
200 hours
While navigating using a paper chart marked WGS84 the OOW plots the ships position by four different
methods and they all give slightly different positions. Which of the following would be considered the
most accurate.Gyro compass bearings from two lighthouses
Selected answer:Correct answer:
Page 3/6
SOLAS (The International Convention for the Safety of Life at Sea) regulations, Chapter 5, deals with the
Safety of Navigation and applies to which vessels?Over 10 000 dwt
Messages sent via INMARSAT C are charged:On the number of kilobits of information transmitted per
block of 1024 bits
*The steps of the embarkation ladder used must be spaced apart by a distance of:200 mm
Equally spaced and not less than 300 mm or more than 380 mm
*Which of following items shall be included in an abandon ship drill?Checking passenger's immersion
suits
Which of the following requirements regarding life-buoys correspond to present regulations? (SOLAS
III/7.1) At least four life-buoys on each side of the ship shall be fitted with buoyant lifelines
Not less than half the total number of lifebuoys shall be provided with self-ignighting lights
Question asked (32121):
Which of these statements about profiling is correct?Check the ID of all visitors and some crew prior to
boarding.
Verify that answers to questions match up with whats already known about the person being
questioned.
Page 4/6
Tank venting systems on chemical tankers should be designed and operated so as to ensure neither
pressure nor vacuum created in cargo tanks during loading or discharging exceeds tank design
parameters. A certain rate of generation of vapour during loading, sometimes termed gas evolution, is
assumed. According to the IBC Code, how is this calculated?The calculated loading rate, assuming a
litreweight of 1.2 kg/l and allowing for a friction loss of 12% per 30 metre length of unrestricted pipeline,
is multiplied by a factor of 1.15 (A safety margin of 20% is additionally applied for products with a
vapour pressure of greater than 1.15 mPa).
What is the minimum permissible distance measured horizontally between the ship's shell plating and
the outer side bulkhead of the first cargo compartment on a type II chemical tanker?Not less than
moulded breadth / 15.
Which of the following is a summary of the tank cleaning requirements for a category "X" substance on a
chemical tanker constructed after 1st January 2007?Strip to 75 litres / 12 miles from land / 25 metres of
water / minimum 7 knots, proceeding en route / discharge below waterline.
Prewash / strip to 75 litres / 12 miles from land / 25 metres of water / minimum 7 knots, proceeding en
route / discharge below waterline.
Monomers.
Cargo residues of certain chemical substances are permitted to be removed by ventilation. What criteria
is applied in determining if a cargo can be cleaned in this way? (Always accepting that local port
authorities may have over-riding regulations on ventilation).That the volume of the tank does not
exceed 1750 cubic metres, that the maximum remaining residues are less than 75 litres and that
ventilation is additionally possible directly down the pumpstack.
Selected answer:
Page 5/6
Correct answer:
That the cargo discharged has a vapour pressure greater than 5 KPa at 20 degrees Celsius.
How would you determine whether a particular cargo transfer hose was compatible with the chemical
product to be transferred?There will be no need to check. If the hose has been supplied to a chemical
tanker, it will have been certified for the transfer of all chemical products.
Refer to the product entry in the hose manufacturer's chemical resistance chart.
You are on a power-driven vessel underway in open water. You sight these lights on the port bow, on a
steady bearing. The distance is closing. What are you looking at and what action will you take in
compliance with the International Regulations for Preventing Collision at Sea?This is a power-driven
vessel engaged in towing, more than 50 metres in length or less than 50 metres in length and showing a
second masthead light, length of tow 200 metres or more, not under command. I will keep clear under
rule 27.
This is a power-driven vessel engaged in towing, less than 50 metres in length, length of tow under 200
metres and the tow, both being restricted in their ability to manoeuvre, seen from the starboard side.
Under rule 18, I am required to keep clear and will take appropriate avoiding action.
Question asked (33651):
The recommended distance between parallel tracks (track spacing) in a search for a casualty by a surface
vessel varies (amongst other factors) according to visibility and the nature of the target in the IAMSAR
Manual. These distances are then normally adjusted for prevailing weather conditions. If visibility was 5
nautical miles and you were looking for a six-person liferaft, what would the recommended uncorrected
track spacing be?2.5 nautical miles.
Which Convention first placed on the shipowner an obligation to exercise due diligence to make a ship
seaworthy, requiring him "before and at the beginning of a voyageto.make the ship
seaworthyandmake the holds...and all other parts of the vessel in which goods are carried, fit and
safe for their reception, carriage and preservation"?The Antwerp Convention.
Page 6/6
What type of dynamic forces may cause indent in plating on forecastle deck and main deck in way of
pillars inside forecastle?Forces created by waves on the forecastle
Recommended