Академический Документы
Профессиональный Документы
Культура Документы
[QG18DE]
DTC P1122 ELECTRIC THROTTLE CONTROL FUNCTION PFP:16119
A
Description UBS00BAY
NOTE:
If DTC P1122 is displayed with DTC P1121 or 1126, first perform the trouble diagnosis for DTC P1121 or EC
P1126. Refer to EC-373 or EC-382 .
Electric Throttle Control Actuator consists of throttle control motor, throttle position sensor, etc.
The throttle control motor is operated by the ECM and it opens and closes the throttle valve.
The current opening angle of the throttle valve is detected by the throttle position sensor and it provides feed- C
back to the ECM to control the throttle control motor to make the throttle valve opening angle properly in
response to driving condition.
D
On Board Diagnosis Logic UBS00BAZ
Harness or connectors
P1122 Electric throttle control Electric throttle control function does not oper- (Throttle control motor circuit is open or
1122 performance problem ate properly. shorted) F
Electric throttle control actuator
FAIL-SAFE MODE G
When the malfunction is detected, ECM enters fail-safe mode and the MIL lights up.
Engine operating condition in fail-safe mode
H
ECM stops the electric throttle control actuator control, throttle valve is maintained at a fixed opening (approx. 5 degrees) by the return
spring.
SEF058Y
WITH GST
Follow the procedure WITH CONSULT-II above.
EC-375
DTC P1122 ELECTRIC THROTTLE CONTROL FUNCTION
[QG18DE]
Wiring Diagram UBS00BB1
BBWA0693E
EC-376
DTC P1122 ELECTRIC THROTTLE CONTROL FUNCTION
[QG18DE]
Specification data are reference values and are measured between each terminal and ground.
Pulse signal is measured by CONSULT-II. A
CAUTION:
Do not use ECM ground terminals when measuring input/output voltage. Doing so may result in dam-
age to the ECM's transistor. Use a ground other than ECM terminals, such as the ground. EC
TERMI-
WIRE
NAL ITEM CONDITION DATA (DC Voltage)
COLOR
NO.
C
Throttle control motor power BATTERY VOLTAGE
3 R/W [Ignition switch: ON]
supply (11 - 14V)
0 - 14V D
[Ignition switch: ON]
Throttle control motor Engine stopped
4 P E
(Close) Shift lever: D (A/T), 1st (M/T)
Accelerator pedal is releasing
PBIB0534E F
0 - 14V
BATTERY VOLTAGE
[Ignition switch: OFF] I
104 P Throttle control motor relay (11 - 14V)
[Ignition switch: ON] 0 - 1.0V
[Engine is running]
116 B ECM ground Engine ground J
Idle speed
: Average voltage for pulse signal (Actual pulse signal can be confirmed by oscilloscope.)
K
Diagnostic Procedure UBS00BB2
BBIA0155E
EC-377
DTC P1122 ELECTRIC THROTTLE CONTROL FUNCTION
[QG18DE]
2. CHECK THROTTLE CONTROL MOTOR RELAY SIGNAL CIRCUIT
Check voltage between ECM terminal 3 and ground under the fol-
lowing conditions with CONSULT-II or tester.
Ignition switch Voltage
OFF Approximately 0V
Battery voltage
ON
(11 - 14V)
OK or NG
OK >> GO TO 8.
NG >> GO TO 3. MBIB0028E
BBIA0102E
PBIB0575E
>> Repair open circuit or short to ground or short to power in harness or connectors.
EC-378
DTC P1122 ELECTRIC THROTTLE CONTROL FUNCTION
[QG18DE]
5. CHECK THROTTLE CONTROL MOTOR RELAY INPUT SIGNAL CIRCUIT FOR OPEN AND SHORT A
1. Disconnect ECM harness connector.
2. Check harness continuity between ECM terminal 3 and throttle control motor relay terminal 3.
Refer to Wiring Diagram. EC
6. CHECK THROTTLE CONTROL MOTOR RELAY OUTPUT SIGNAL CIRCUIT FOR OPEN AND SHORT
1. Check harness continuity between ECM terminal 104 and throttle control motor relay terminal 1. E
Refer to Wiring Diagram.
Continuity should exist.
F
2. Also check harness for short to ground and short to power.
OK or NG
OK >> GO TO 7. G
NG >> Repair open circuit or short to ground or short to power in harness or connectors.
8. CHECK THROTTLE CONTROL MOTOR OUTPUT SIGNAL CIRCUIT FOR OPEN OR SHORT J
EC-379
DTC P1122 ELECTRIC THROTTLE CONTROL FUNCTION
[QG18DE]
9. CHECK ELECTRIC THROTTLE CONTROL ACTUATOR VISUALLY
1. Remove the intake air duct.
2. Check if foreign matter is caught between the throttle valve and
the housing.
OK or NG
OK >> GO TO 10.
NG >> Remove the foreign matter and clean the electric throttle
control actuator inside.
BBIA0178E
PBIB0098E
EC-380