Академический Документы
Профессиональный Документы
Культура Документы
Owners Manual
Components III. Turning your remote train
! Transmitter selecting operating mode
! Receiver with collar Mode
! Training Manual automa
! Owners Manual conserv
! Video
Locate th
receiver
I. Assemble collar Step 1: Thread slide connect seconds
buckle onto the collar first.
Important Note: Slide buckle also prevents collar from
becoming loose around your dogs neck.
Important Note: Ribs must be facing up, otherwise collar will slip if it is
not properly threaded.
9 volt
battery remove
screws (2) remove
screws (2)
Long
Beep
Big Dog receiver Little Dog receiver
2
III. Turning your remote trainer on &
selecting operating mode
Mode 1. Automatic Shut-off. Receiver shuts off
automatically after 45 minutes of non-use to
conserve battery power.
3
IV. Set the correction level Signal
indicator
light
To Program Correction level, hold down the P button. After
2 seconds, the receiver will indicate the present correction Correction
with negative
level setting by beeping the corresponding number of times tone.
for the current level. Negative
Continue to hold the P button down until the number of tone only
beeps equals the level of correction you want. Program
After Level 8, the receiver will go back to Level 1. button
Please read the training manual thoroughly and review the video before
beginning training.
VII. Maintenance
Perform each of the following:
] Check batteries (monthly).
] Clean probes with alcohol (weekly).
] Be sure that the probes are tightened securely to the receiver (monthly).
] Check your pets neck for any irritation (daily).
Caution: To reduce risk of electric shock, DO NOT REMOVE COVER. Refer to qualified service personnel. Risk of fire.
Risk of electric shock. Install Transmitter indoors. Do Not expose to rain. 14VAC 1.8A This device complies with part 15
of the FCC Rules. Operation is subject to the following two conditions: 1. This device must not cause harmful interference 2.
This device must accept any interference received including interference that may cause undesired operation.
FCC ID: KE3IF100
Radio Systems Corporation, 10427 Electric Ave., Knoxville, TN 37932
1-800-732-2677 www.radiosys.com
400-206/B
4