Академический Документы
Профессиональный Документы
Культура Документы
com/catalog/cat/content/i01830621/
Usage:
315C ANF 312C BNN 318C BTG 312C L CBT 318C DAH 318C FAA 319C KGL
Note: Machines that are equipped with a System G14 have an additional Implement ECM. In
order to replace the Implement ECM, follow the procedure below.
Prior to replacement of the Implement ECM, ensure that replacement is absolutely necessary.
The Implement ECM is not normally the cause of a diagnostic code. Always check that power
is available to the Implement ECM and the monitor. Battery voltage is required at contact 1 of
connector 1. Ground is required at contact 2 of the harness connector for the Implement ECM.
When the Implement ECM is replaced, adjustments or calibrations are required. Refer to
Testing and Adjusting, "Proportional Reducing Valve - Calibrate" and Testing and Adjusting,
"Governor Actuator - Calibrate".
1. Turn the disconnect switch and the keyswitch to the OFF position.
4. Verify that the replacement for the Implement ECM has the correct part number.
9. Calibrate the electronic governor. Refer to Testing and Adjusting, "Governor Actuator-
Calibrate".
10. Calibrate the proportional reducing valve. Refer to Testing and Adjusting, "Proportional
Reducing Valve - Calibrate".
PARTS
Caterpillar
Hitachi
AUTODATA
Caterpillar SIS
Volvo Impact
Volvo Prosis
Hitachi HOP
Bosch ESPI
Spare parts