Академический Документы
Профессиональный Документы
Культура Документы
Type HD
Malleable iron, SG iron, corrosion protection as requested Type HD Hard / Soft Clip Plug
Nose
Leg
Skirt
Elastomer Spring
The type HD rail clamps facilitate the precise alignment of rails by allowing
a high degree of stepless lateral adjustability. Three variants are available
(see opposite page).
Technical Data
Suitable for all rails with tapered flanges and crane speeds of up to
60m/min. For wheel loads above 400kN or lateral loads higher than
wheel loads please contact Lindapter.
NB: Leg length V for use with rail sections only with tapered base. For parallel sections please refer to Lindapter.
Leg length V should be selected to clamp rail down tightly and allow no
vertical rail movement. Not to be used when the rail is supported by a
resilient pad. H
F V
Y X B
A
The spring clip version incorporates an elastomer spring into the nose
of the product, designed to provide some vertical restraint to the rail
whilst still allowing the rail to lift with rail wave.
The elastomer spring is manufactured from high density synthetic H
polymer which has a Shore A hardness of 94.97. The spring is F V
unaffected by salt water and most chemicals and has a high resistance
to abrasion. Y X B
A
Resilient Pad
Both the spring and soft clips can be used with a resilient pad to
decrease track running noise / structural vibration, level out irregular
contact between surface and rail and to spread wheel load evenly over V
a wider area.
Resilient Pad