Академический Документы
Профессиональный Документы
Культура Документы
MOD UINTERFREQNCELL: RNCId=XXXX, CellId=High load cell, NCellRncId=XXXX, NCellId=Low load Cell,
SIB11Ind=TRUE, IdleQoffset1sn=0, IdleQoffset2sn= -5;
UINTERFREQNCELL IdleQoffset2sn 5
MOD UINTERFREQNCELL: RNCId=XXXX, CellId=low load cell, NCellRncId=XXXX, NCellId=high load Cell,
SIB11Ind=TRUE, IdleQoffset1sn=0, IdleQoffset2sn=3;
UINTERFREQNCELL IdleQoffset2sn 3
Note (The load in the same sector can be adjusted. M2000 1 min monitoring can be used to analyse the load balancing
has been triggered).
PCPICHPOWER 330
Trigger when cells have been detected as bad access performance due to resource limitation. RRC Congestion
rate is more than 10% and CS blocking rate is more than 5%.
Note (When reducing the CPICH all the cells (layers) in the sector have to be on same level for example if degradation is
observed on 209682_SurryHillsNorth_MO_U21A_3 and CPICH has to be reduced it will be done for both carriers
209682_SurryHillsNorth_MO_U21A_3 and 209682_SurryHillsNorth_MO_U21B_3.
SET GCELLCCUTRANSYS: IDTYPE=BYID, CELLID=***, FDDQMIN=5; (2G Command have to be executed on the BSC MML)
Parameter Name Sub Parameter Value SE Parameter Baseline
UCELLSELRESEL SsearchRat 3 1
GCELLCCUTRANSYS FDDQMIN 5 6
Step 4 Push More traffic from 3G - 2G
SET GCELLCCUTRANSYS: IDTYPE=BYID, CELLID=***, FDDQMIN=3; (2G Command have to be executed on the BSC MML)
Parameter Name Sub Parameter Value SE Parameter Baseline
UCELLSELRESEL SsearchRat 4 1
GCELLCCUTRANSYS FDDQMIN 3 6
Works great with GSM co-site can also be implemented on the tier 1 neighbours than other GSM neighbouring cells can
be changed according to the congestion.
Note (The modification should be according to distance between SE areas to the related site, only the very near Main
SE site can be modified. Otherwise, it will impact the user experience. This parameter should only be implemented as a
last resort and extreme values can be changed to Qrxlev = -50, Qqualmin=-14.