Академический Документы
Профессиональный Документы
Культура Документы
Setup of the Lantronix Com Port Redirector with FL COMSERVER ... 232/422/485
02 Com Port Redirector v4.3.0.0 Supports Win7, 2008 Server, 32 and 64 Bit
1 Overview
This document describes the configuration of FL COMSERVER 232/422/485 and the Com Port
Redirector software v4.3.
The firmware of the FL COMSERVER 232/422/485 must be version E2.20 or higher.
Actual firmware is available in the Download Center of Phoenix Contact.
PHOENIX CONTACT GmbH & Co. KG Flachsmarktstrae 8 32825 Blomberg Germany 1/11
Phone: +49-(0) 5235-3-00 Fax: +49-(0) 5235-3-4 12 00 www.phoenixcontact.com
Setup of the Lantronix Com Port Redirector with FL COMSERVER ... 232/422/485 Quick Reference Guide
The delivery status supports the com port redirector application. Following settings are required to
establish a TCP connection from the redirector to the FL COMSERVER 232/422/485.
The CPR installer starts and displays the required software packages. It depends on an already
installed Microsoft .NET Framework v4.0.
If the Microsoft .NET Framework v4.0 is already installed on the machine, the installer will continue
with the redirector installation (next page). Please agree to license terms to continue.
Complete the Microsoft .NET Framework v4.0 installation with Finish. The Com port redirector
installation will start.
Launch the installation with Next and exit the routine with Close.
The CPR Manager starts and displays the actual com port configuration.
Use the Add/Remove-button to create new virtual com ports on the system.
Select the new virtual com ports and confirm with OK.
New created com ports will be displayed in the main configuration overview and need to be
configured. Select the first new virtual com port. As long the settings are not saved, the description
information will be displayed in red.
Type in first the IP-address and TCP-port of the FL COMSERVER 232/422/485 and save the
configuration using the Save-button.
After you have saved the configuration, you can test the network connection to the
FL COMSERVER 232/422/485. Select the Com X Tests tab and establish a network
connection to the device by using the Open-button.
The Network Status will display the successful established network connection.
The configuration is finished and the virtual com ports can be used by the application software of
the system.