Академический Документы
Профессиональный Документы
Культура Документы
Engineering School
Technical English 3
1. __________ can be heated by solar energy by the use of roof-mounted devices consisting
of heat collectors through which pipes pass.
a) Plastic
b) Wood
c) Oil
d) Water
a) Engine
b) Photovoltaic cell
c) Transformer
d) Power turbine
3. This component consists of specially covered plumbing that is used to absorb the radiation
of the sun and to change it into heat.
4. Devices used in distant places as a source of power for water floats and for pumps for
watering lands:
a) Accumulators
b) Solar batteries
c) Generators
d) All of the above
a) Germanium
b) Silicon
c) Diamond
d) Zinc
Universidad de San Carlos de Guatemala
Engineering School
Technical English 3
a) Light posts
b) Power grid
c) Light bulbs
d) Backup plant
2. Horizontal axis wind turbines have the main __________ and electrical generator at the top
of a tower, and they must be directed into the wind.
a) Mechanism
b) Engine
c) Blade
d) Rotor
3. This type of wind turbine design has been utilized traditionally for different tasks, but not
commonly to produce electricity in major dimensions.
a) Lift
b) Horizontal Axis
c) Drag type
d) Vertical Axis
4. With rotors situated near to the ground where wind speeds are inferior is an example of
the inconvenient in the __________ wind turbines.
a) Lift
b) Horizontal Axis
c) Drag type
d) Vertical Axis
5. These special types of wind turbines have a problematic because they generate big
rotation ripple and cyclical stress located on the tower, situation that adds reduced
trustworthiness.
a) Darrieus
b) Savonius
c) Drag type
d) Horizontal axis
Universidad de San Carlos de Guatemala
Engineering School
Technical English 3
Gears Worksheet
Instructions: The students will have 5 minutes for reading the topic Gears, after that, they
will answer the following questions (without the book):
2. The ratio of a gear system composed by a 8-cm diameter gear and a 2-cm diameter
gear is?
3. What is involute?
6. Why helical gears are most used in car transmission than spur gears?
9. Rack and pinion gears are slightly different from the other gears? Which is their principal
function?
11
b.
1
0
c.
1
d.
3. The figure below shows a logic circuit and its incomplete truth table. Complete the below truth table.
A B C Q
A
C Q 0 0
B 0 1
1 0
1 1
4. The figure below shows a logic circuit and its incomplete truth table. Complete its truth table.
A C A B C D Q
Q 0 0
B
0 1
D
1 0
1 1
5. The figure below shows a logic circuit and its incomplete truth table. Complete the below truth table.
A A B C D Q
C
Q 0
0
D 1
B
1
6. The figure below shows a logic circuit and its incomplete truth table. Complete the below truth table.
A
C A B C D Q
Q
0
B 1
D
0
1
A B D
A
0 0
D
0 1
B 1 0
1 1