Академический Документы
Профессиональный Документы
Культура Документы
powered by Archive
work MLive.com - Wings' practice 2008 (216)
prescription: work on defence and Nov 2008 (14)
Man Burned In
explosion hurts
Thursday, 31 July 2008 worker
Apparent gas
explosion at coal
mine hurts two
Fitter killed by exploding tyre Clocks go back
A fitter died when a tyre he was putting on a 17-tonne tanker HSE issues
exploded while he was inflating it.
advice for safe
The accident happened at an industrial estate in Waldingfield Road, workin...
Sudbury, Suffolk, where he was changing a tyre. Work resumes on
in China down
Industrial incident 20% in past 10
mont...
An East of England Ambulance Service lay responder was first to Stay at home if
reach the merchants' yard and applied first aid.
you're sick, say
An ambulance arrived within four minutes of the emergency call and bosses
the air ambulance 10 minutes later. Arkoma
explosion hurts
A spokesman for Chilton Grain said that the man had been on the site worker
Man cautioned
changing the tyre on the tanker lorry for about an hour.
over bogus
"While he was inflating the tyre on the heavy lorry it failed and
exploded. The force hit him in the head and he was knocked under insurance claim
the trailer," he said. Safety stats "a
The little girl had been walking with her mother close to their home
when the accident happened.
She was rushed to nearby Glan Clwyd Hospital but was pronounced
dead on arrival.
Her parents Peter and Lindsay Burgess yesterday visited the scene
100 yards from their home, where relatives and friends have laid
flowers and teddy bears.
Mrs Burgess, 28, a photographer, said Meg was "the most perfect
daughter in the world."
A statement read by Meg's uncle said the couple, who have a baby
son called Wilson, were "horrified by this horrible, tragic event, that
has affected their's and so many other lives forever."
The wall, at least six feet tall, was on land adjoining a house which is
being renovated.
"The roads are a major hazard, and they are also a major source of
employment with the likes of lorry, van, bus and taxi drivers and
sales staff all making use of the roads to earn their living."
"Work factors can often affect these people. For instance, if theyre
forced to drive for long hours or are put under excessive targets,
causing stress. These in turn can have devastating impacts on the
person and on other road users. Its in these sort of situations where
accidents need proper investigation by health and safety experts so
that lessons on the causes of the accident can be learnt by
employers."
"It seems the roads are the one place where employers will continue
to be able to get away with putting their workers lives, and those of
others, at risk. Work-related road deaths are a gaping hole in our
health and safety recording," Ray concluded.
Source.
at 02:51 0 comments
Labels: accident, fatality, injury, IOSH, news, RIDDOR,
road
Employers have been warned that from October 2009 they must
aware new guidelines governing the number and category of first aid-
trained staff come into force.
Anna Brown, head of customer services for the British Red Cross first-
Source.
Thirteen people were killed when a minibus taxi in which they were
travelling was involved in a collision with two trucks and two cars near
Ladysmith in KwaZulu-Natal on Thursday.
"The taxi was completely ripped open and the majority of the
passengers were flung out on to the road. Some bodies were found
under the truck.
"We are still reconstructing the accident so we can't, at this stage, say
how many people were in each vehicle," Struwig said.
She said the accident was one of the most gruesome she had seen in
her career. The road was closed to traffic for about seven hours while
authorities cleared the wreckage and recovered the bodies.
A cement firm has been fined 200,000 after a quarry worker was
permanently scared when he fell into the blades of a fan.
Welder Stuart Richardson lost an ear and needed bone plates and
screws to his mouth after the incident at the Dunbar Works in East
Lothian.
Mr Richardson fell into the uncovered electric fan as he was working
on the motor of the quarry's stacker machine - which crushes
limestone to make cement.
He was taken to Edinburgh Royal Infirmary and later transferred to St
Johns' Hospital in Livingston for specialist treatment.
Lafarge Cement admitted two offences under health and safety laws
at Edinburgh Sheriff Court
Sheriff Kenneth Maciver said: "I'm satisfied and I think the Health and
Safety Executive is satisfied that steps have been taken."
(CAT) to safely detect electric current and avoid, the electricity supply
to the house.
Mr Richardson's workmate said they had been shown how to use a
CAT during '20 or 30 minutes' as part of a training course in 1998, but
they had never achieved competence in its use.
HSE Inspector, Trevor Morrow, said:
"The CAT they were trained on was a different model to the one that
was kept at Dacorum Borough Council, so they would have had to be
trained again. If it had been available as part of their normal
excavation work and they had been competent in its use, then the
CAT would have prevented this fatality.
"I hope this tragic incident makes it clear to employers that they need
to take positive steps to risk assess the obvious hazards involved with
underground work, such as electricity and gas, and to manage them.
They must ensure that staff are properly trained in the use of
detection equipment, such as a CAT, and are aware of the potential
risks involved in this type of work."
Notes
Section 2 of the Health and Safety at Work etc Act 1974 states "It
shall be the duty of every employer to ensure, so far as is reasonably
practicable, the health, safety and welfare at work of all his
employees."
have not been released but Network Rail said it was investigating.
"I immediately had a spot like when you stare into the sun," rave-
attendee Dmitry told Kommersant.
"After three days I decided to go to the hospital. They examined me,
asked if I had been at Open Air, and then put me straight in the
hospital. I didn't even get to go home and get my stuff," he said.
Cosmic Connection, promoters of the Aquamarine rave, were
unreachable and did not list contact numbers on their Web site.
Industry Web site www.laserfx.com said focused laser light can cause
eye damage almost instantly.
"It was partly the rain, but also partly the size of the laser. Somebody
set up an extremely powerful laser for such a small space," said
Valentin Vasiliev, who said his company did not provide the
Aquamarine lasers.
It is believed the woman was trying to get out of the lift at Rodgers
Towers in Maryhill after it became stuck between the eighth and ninth
floors.
The 32-year-old was taken to hospital but died a short time later.
Strathclyde Police said the woman died after falling nine floors down
the shaft at Wynford Road.
The lifts in the block are run by the Cube Housing Association.
"Our staff are now working with the police and health and safety
personnel to try to ascertain how this accident occurred.
It was widely reported that a fire station was built without the
traditional pole for 'health and safety' reasons.
Poles are not banned and firefighters around the country continue to
use them.
at 06:01 0 comments
But concerns have been raised over the high levels of fatalities in the
agriculture and construction sectors, with deaths in the former rising
from 36 in 2006/07 to 39 in 2007/08.
HSE chair Judith Hackitt welcomed the drop in fatalities but warned
there was no room for complacency, pointing out that the report
suggests a plateau in the overall five year trend.
The figures, which are up from 51 in 2006 and 74 in 2005, show most
of the rise in fatalities occurred in the fishing and construction sectors.
About 14% of the all accidents reported to the HSA involved non-Irish
national workers. A total of 13,631 workplace inspections were carried
out in 2007 and enforcement action taken in 12% of those workplaces.
Original article.
at 01:36 0 comments
Labels: accident, fatality, news
In construction there were 72 fatal injuries and the rate of fatal injury
was 3.4 deaths per 100 000 workers. Although the last 15 years
overall has shown a downward trend in the rate of fatal injury to
workers, the recent five years has shown little change, with an
average yearly rate of 3.6.
In the services sector there were 74 fatalities, and the rate of fatal
injury was 0.30 deaths per 100 000 workers. Since 1998/99, the trend
in the rate of injury in this sector has remained relatively unchanged.
The men, both of Shortgate, near Lewes, East Sussex, were each
charged earlier this month with two counts of manslaughter.
Geoffrey Wicker, 49, and Brian Wembridge, 63, both died while
tackling a blaze at the firework depot in Sussex in 2006.
Twelve other people were injured in the explosions and blaze near
Ringmer, including nine firefighters and a police officer.
The father and son were granted bailed to appear at a further hearing
at Lewes Crown Court on September 3.
Original article.
at 01:43 0 comments
Labels: explosion, fatality, firefighters, fireworks,
prosecution