Академический Документы
Профессиональный Документы
Культура Документы
fillet behind the TOGS box. This was offers two versions the recommended is curved and is solid. This was achieved
recreated using 20x60 thou strip. one with the location sockets for the by simply gluinging a small piece of 001
jerrycan holder (part D43) and the earlier thou brass sheet round the front part of the
Tamiya provide the TOGS box with a version (part B7) without these features. I mesh.
separate door but no internal detail. I used the earlier version. The reason for this Forward of this bin is another mesh bin,
Although not essential, I decided to rebuild The jerrycan holder on the turret was The stowage bins on the rear corners of
the forward stowage basket from scratch. originally designed to carry a jerrycan on the turret benefit from additional detail.
Using the kit part as a guide. Instead of its side, however, it was modified when Both had a 10x40 thou strip added to the
using the kit-supplied flexible mesh I fitted to the turret so that the jerrycan sat inside edge, detailed with bolt heads. This
looked around for a better way of vertically. A metal bar was therefore added retains a nylon cover on each bin that I
portraying the rectangular mesh on the across the base of the holder. Note that it recreated using thin pewter foil. but
actual vehicle. Aber came to my rescue also sits higher up than portrayed on the contains little or no lead. Straps were
with a small fret of this style of mesh (S 13 kit (although this can vary from vehicle to added using masking tape and etched
in their listings). Over the top of the bin I vehicle). buckles.
added the nylon cover from thin pewter
34 35