Академический Документы
Профессиональный Документы
Культура Документы
SA-209/SA-209M
5. General Requirements
2. Referenced Documents 5.1 Material furnished under this specification should
2.1 ASTM Standards: conform to the applicable requirements of the current
A 450/A450M Specification for General Requirements edition of Specification A 450/A 450M, unless otherwise
for Carbon, Ferritic Alloy, and Austenitic Alloy Steel provided herein.
Tubes
A 941 Terminology Relating to Steel, Stainless Steel,
Related Alloys, and Ferroalloys 6. Manufacture
6.1 Steelmaking Practice The steel shall be killed.
3. Terminology 6.2 The tubes shall be made by the seamless process
3.1 Definitions For definitions of terms used in this and shall be either hot-finished or cold-finished, as spec-
specification, refer to Terminology A 941. ified.
327
--`,,```,,,,````-`-`,,`,,`,`,,`---
328
TABLE 1
CHEMICAL REQUIREMENTS
Composition, %
Element Grade T1 Grade T1a Grade T1b
TABLE 2
NUMBER OF TUBES IN A LOT HEAT TREATED BY THE CONTINUOUS PROCESS
Size of Tube Size of Lot
2 in. [50.8 mm] and over in outside diameter and not more than 50 tubes
0.200 in. [5.1 mm] and over in wall thickness
2 in. [50.8 mm] and over in outside diameter and not more than 75 tubes
under 0.200 in. [5.1 mm] in wall thickness
Less than 2 in. [50.8 mm] but over 1 in. [25.4 mm] not more than 75 tubes
in outside diameter
1 in. [25.4 mm] or less in outside diameter not more than 125 tubes
TABLE 3
TENSILE REQUIREMENTS
Grade Grade Grade
T1 T1b T1a
A
Table 4 gives the computed minimum values.
329
TABLE 4
COMPUTED MINIMUM VALUES
Wall Thickness
Elongation in 2 in. or
in. mm mm, min, % A
5
16 (0.312) 8 30
9
32 (0.281) 7.2 29
1
4 (0.250) 6.4 27
7
32 (0.219) 5.6 26
3
16 (0.188) 4.8 24
5
32 (0.156) 4 22
1
8 (0.125) 3.2 21
3
32 (0.094) 2.4 20
1
16 (0.062) 1.6 18
A
Calculated elongation requirements shall be rounded to the nearest whole number.
TABLE 5
HARDNESS REQUIREMENTS
Brinell Hardness Rockwell Hardness
Number (Tubes 0.200 Number (Tubes less than
in. [5.1 mm] and over in 0.200 in. [5.1 mm] in
Wall Thickness) Wall Thickness)
330
SUPPLEMENTARY REQUIREMENTS
The following supplementary requirement shall apply only when specified by the purchaser
in the inquiry, contract, or order.
331
332