Академический Документы
Профессиональный Документы
Культура Документы
Cairo Campus
EC339 Electronics 2
Lab Report
Exp. No.: 7
Name :
ID No. :
Class : ...
Grade:
Lab-7 Op-Amp Applications (Integrator - Differentiator) EC339 Electronics 2
Objective:
Theory:
Integrator
Design Equations:
Circuit Diagram:
Figure 1.
1
Lab-7 Op-Amp Applications (Integrator - Differentiator) EC339 Electronics 2
Equipment:
Procedure:
1- Configure the function generator to output a square wave with a frequency of 1k
Hz and peak amplitude of 1 V with a 0 V DC offset.
2- Build the circuit shown in circuit figure 1 on your breadboard.
3- The voltage source will be your function generator
4- Set the function generator with the input signal that you obtained from 1.
5- Use the oscilloscope to view the output at pin 6 on the oscilloscope channel 2 and
the input voltage on channel 1.
6- Set the horizontal scale to show three periods.
7- Plot the input voltage and output voltage on Graph 1.
2
Lab-7 Op-Amp Applications (Integrator - Differentiator) EC339 Electronics 2
Circuit Diagram:
Figure 2.
Equipment:
Procedure:
1- Configure the function generator to output triangular wave with frequency of1k Hz
and peak amplitude of 5V with a 0 V DC offset.
2- Build the circuit shown in circuit figure 2 on your breadboard.
3- The voltage source V1 will be your function generator.
4- Set the function generator with the input signal that you obtained from 1.
5- Use the oscilloscope to view the output at pin 6 on the oscilloscope channel 2 and
the input voltage on channel 1.
3
Lab-7 Op-Amp Applications (Integrator - Differentiator) EC339 Electronics 2
4
Lab-7 Op-Amp Applications (Integrator - Differentiator) EC339 Electronics 2