Академический Документы
Профессиональный Документы
Культура Документы
731A
REPAIR TIP
R.T. 06-23 REVISED
Call Code: as required OCT., 2007
Job Code: Mfg. Ref. # N/A
56100E Console Test /
Program monitor REMOVE AND REPALCE
53032J Replace / Adjust DIV. 06 R.T. # 06-23
Control Board DATED: JANUARY 2004
SUPPLIER# C249
BR PROC ID:
PRS PROC ID: MAUICE PINCOFFS
Internal Use Only
BRAND FREE SPIRIT
PRODUCT TREADMILL
1. MONITOR CALIBRATION
2. PROCESS OF CHANGING THE ALATECH SYSTEM
3. PROCESS OF CHANGING THE CONTROL BOARD
On Model C249 30686
STEP 1:
Turn on the power for the monitor by pressing the on switch located on the front
of the treadmill.
STEP 2:
Please find the 4 holes located on backside of the console. These 4 holesare marked with R
(Reset Speed), I (Incline set), H (High Speed set) and L (Low Speed set).
STEP 3:
Press the button of R with a stick. Do not use metal material as this will affect the monitor
function.
STEP 4:
Press START button.
STEP 5:
The speed will display at 1.6 km/h or 1.0mph.
STEP 6:
Press the button of L to set low/start speed.
STEP 7:
Press the FAST button till the speed display at 16km/h or 10.0mph.
STEP 8:
Press the button of H to set high speed.
STEP 9:
You can press the FAST button to ensure that the speed will not go over the high speed
you set.
STEP 10:
Press the STOP button.
STEP11:
Press the button of I to reset incline.
STEP12:
The treadmill will run incline function automatically for a cycle (from down to up).
STEP: 13
The treadmill reset has been completed when the pulse / incline icon display is at 00.
1
Incline power cords must be set in order as
black, white, and red. Accordingly to the
picture on the left side
2
There are two magnets in the front roller.
One of them needs to be pulled out during
the change.
After correction, please help to make sure
one of them doesnt have magnetic and
another one does.
3
Fix the cable you updated in the former
way. As the left picture shows
4
The fixed position is showed in the left
picture.