Академический Документы
Профессиональный Документы
Культура Документы
View of completed model * This model was designed for Papercraft and may differ from the original in some respects.
Key to symbols
Mountain fold Fold so that the printed pattern faces outside. Dots indicate parts to be glued;
Dotted line
dotted lines indicate approximate area for
application of glue.
Valley fold Fold so that the printed pattern faces inside.
Dashed and
dotted line
Red dot Glue parts with the same number together.
Cut a notch Cut along the center of the line.
Solid line along this line.
Green dot Glue areas within the same part together.
Cut a notch
along the line. Cut these areas out. Blue dot Glue to the reverse side of the specified part.
Scissors mark
Do not
glue here.
*Right side
*Left side
Front
Carefully shape curves.
*The numbers inside the parentheses are given to the
Confirm top/bottom before gluing. Affix with glue. parts for lights with a small center.
*Left side
*Right side
Fold it in half, and catch the pasting margin of Part 52 and glue.
Carefully shape
*Pay attention because the part numbers of the left and right are different.
curves.
Confirm top/bottom
The joining part is the before gluing.
lowest point.
Pink flap indicates outer side.
Top
The joining part is the lowest point. Affix outer surface of tire like a bowl,
then wait until glue is dry before gently
Apply glue around the mountain fold pulling the tire into shape.
lines and adhere them. The joining part is the lowest point.
Glue in order, - .
Joint should be positioned at the top.