Академический Документы
Профессиональный Документы
Культура Документы
ARCHITECTURAL COATINGS
TOUCHWOOD
www.asianpaints.com/oman Wood Stain (SBZ)
PRODUCT DESCRIPTION
BERGER Touchwood wood stains (SBZ) have been formulated specially for concentrated use.
These stains are very high in strength and can be applied directly or post application of AC lacquer on the wood and can be
further overcoated with AC lacquer.
These stains are recommended only for interior use.
TECHNICAL DATA
Shade / Colour Range : Available in limited colours.
Composition Nominal : Dyes dissolved in solvent.
Specific gravity : 0.93 - 0.95
Practical coverage Capacity : Coverage may depend on surface profile, method of application & geometry of the substrate.
APPLICATION DATA
SURFACE PREPARATION
In case of grease / oil contamination use Universal Thinner for cleaning the surface before sanding with suitable abrasive
paper.
For larger area wire brush can be used for removal of old paint.
For old and strongly adhered paint film on wooden surface BERGER Quick Paint Remover should be used for stripping the
paint.
Note : Sanding should be done along the grains only.
APPLICATIONS DETAILS
Stir the contents thoroughly before and during use.
Apply 1-2 coats of Wood stain directly or by thinning with Touchwood NC Thinner for lighter shade or apply 1 coat of AC
lacquer (Silkmatt / Matt) or AC Sealer, let it dry for 30 to 45 minutes, sand it using emery paper no. 400, wipe the surface
with clean / dry rag then apply the stain by spray application.
* For detailed system recommendation based on specific requirements please contact Berger representative.
DISCLAIMER
The information provided in this data sheet is not intended to be complete. It is the responsibility of the user to ensure that the product used is suitable for the purpose it is meant to serve.
In view of various factors affecting the performance of the coating, we cannot assume responsibility for the product performance, nor do we accept any liability arising from use of this
product, unless specifcally agreed to in writing by us. The information provided in the datasheet may be modifed by us without notice.
This Technical Data Sheet supersedes those previously issued with immediate effect.
Version: 02/2007