Академический Документы
Профессиональный Документы
Культура Документы
Ordering
Pricing
Lifetime Warranty
Features
Disk Diagnostics
Disk Duplication
File Recovery
Password Removal
Firmware Recovery
Disk Utilities
Case Management
Information
FAQ
Version log
Once everything is set up, click OK. Make sure that you have attached everything correctly by applying power to
the drive (you should see a meaningful output in the terminal window).
Products
Note: if you make an error while entering commands, you will get the following message:
Atola Insight
Atola Disk Recycler In this case simply re-enter the command and double-check that you are entering everything exactly as shown
in this manual.
Once everything is ready and you have powered on the drive, you should see the following (or very similar)
output in the terminal window:
Rst 0x20M
At this point press CTRL+Z. You should receive the command prompt:
F3 T>
Max Wr Retries = 00, Max Rd Retries = 00, Max ECC T-Level = 00, Max Certify Rewrite Retries = 0000
4. Wait some more time until you see the command prompt again:
F3 T>
5. Type the following: /2 and then press ENTER. You will see the following output:
F3 T>/2
F3 2>
F3 2>Z
7. At this point you have to re-power the drive. The procedure is complete.
Rst 0x10M
LED:000000CC FAddr:0025BF67
3. Put a piece of paper as shown on the picture below (the goal is to separate spindle motor contacts from the
pcb):
http://atola.com/products/insight/manual/seagate-7200.11.html 2/4
Seagate 7200.11 Hard Drives - Atola Insight Online Manual 3/30/13
4. If you detached any cables from the drive, this is the right time to attach them back.
5. Apply power to the drive (with screws removed and paper inserted) and wait for the drive to become ready
(usually no more than one minute)
6. You will see the following (or very similar) output in the terminal:
Rst 0x20M
F3 T>
8. Type the following: /2 and then press ENTER. You will see the following output:
F3 T>/2
F3 2>
F3 2>Z
10. Now remove the paper, put all screws back and tighten them (do not power off the drive!):
http://atola.com/products/insight/manual/seagate-7200.11.html 3/4
Seagate 7200.11 Hard Drives - Atola Insight Online Manual 3/30/13
F3 2>U
Spin Up Complete
Elapsed Time 6.604 secs
F3 2>
12. Type the following: /1 and then press ENTER. You will see the following output:
F3 2>/1
F3 1>
13. Type the following: N1 (capital N and one) and then press ENTER. You will see the following output:
F3 1>N1
F3 1>
14. Re-power the drive (press Power Off button on the DiskSense unit; wait 10-15 seconds; press Power On
button) and wait until it initializes:
Rst 0x20M
F3 T>
16. Type the following: i4,1,22 and then press ENTER. You will see the following output:
F3 T>i4,1,22
F3 T>
17. At this point do not re-power the drive, scroll to the top of this page and go through Fixing zero capacity
problem starting from step 1.
Home Products Where to Buy Support Company Privacy Copyright 20032013 Atola Technology
http://atola.com/products/insight/manual/seagate-7200.11.html 4/4