Академический Документы
Профессиональный Документы
Культура Документы
epoxy resin mortars for different applications. The resin Flexural strength : 40 N/mm2
system is formulated to bond to both dry and damp
surfaces. Bond strength : > 2.5 N/mm2
(Failure in concrete)
FIELDS OF APPLICATION Chemical Resistance
CONCRESIVE 2525 adheres to most surfaces after CONCRESIVE 2525 resists most common organic and
proper preparation. It is recommended to be held always inorganic acids in diluted form, alkalis, oils, grease, fuels,
in stock as a general purpose epoxy system that can be water, etc.
used with suitably graded fillers for a variety of Chemical resistance depends on the chemicals involved,
unforeseen applications that arise on sites frequently, their concentrations, temperature and degree of
such as; exposure. Good housekeeping practices such as
bonding fresh concrete to set concrete especially at immediate clean up of all spillages will greatly extend the
construction joints. service life.
bonding cementitious repair mortars or steel to
concrete or mortar substrates. PROPERTIES
grouting of anchor bolts, dowels, etc. Part A Part B
rapid repairs to structural concrete. Supply form liquid liquid
patch repairs to floors, stair case noses, walls, etc.
Colour Clear Amber
Note: While CONCRESIVE 2525 is a versatile resin
system, its performance depends entirely on the Mixed system
proportion, type and grading of fillers used and the Mix ratio (A:B) by volume : 3:1
method of application followed. Colour : Amber
For jobs planned in advance, it is recommended to Density : 1.090.01 kg/L
select a BASF Construction Chemicals product Application temperature range : 5C - 30C
designed for the specific type of application to achieve Minimum cure temperature : 5C
optimum results. Pot life at 25C (1 L) : 30 mins.
FEATURES & BENEFITS APPLICATION
High elastic Effective transfer of stresses at bond Surface preparation
modulus interface. Correct substrate preparation is critical for optimum
Versatile No need to stock several different performance. Surfaces should be structurally sound,
types of resin systems for emergency clean, and free from loose particles, oil, grease, or any
use. other contaminants.
Excellent Renders the bonded parts monolithic. Remove oil grease and wax contaminants by scrubbing
adhesion Minimises water ingress through cold with industrial grade detergent or degreasing
joints. compounds followed by mechanical cleaning. Cement
Good bond to Advantage while bonding fresh laitence, loose particles, mould release agent, curing
damp concrete or mortar and in humid membrane, and other contaminants must be removed
surfaces environments. from the surface by wet grit blasting, high pressure water
Pre- Avoids batching errors of resin jetting (approximately 150 bars) or such other effective
proportioned system. Minimises wastage. methods.
Make other necessary preparations specific to the type
of application.
Mixing
Mechanical mixing is necessary. A slow speed (600
rpm) drill, fitted with a helical or a rod type paddle
depending on the filler content, is recommended.
1-1-1-1106
The technical information and application advice given in this BASF Construction Chemicals
publication are based on the present state of our best scientific and practical knowledge. As the
STATEMENT OF information herein is of a general nature, no assumption can be made as to a product's suitability for a
RESPONSIBILITY particular use or application and no warranty as to its accuracy, reliability or completeness either
expressed or implied is given other than those required by law. The user is responsible for checking the
suitability of products for their intended use.
Field service where provided does not constitute supervisory responsibility. Suggestions made by
BASF Construction Chemicals either orally or in writing may be followed, modified or rejected by the
NOTE owner, engineer or contractor since they, and not BASF Construction Chemicals, are responsible for
carrying out procedures appropriate to a specific application.