Академический Документы
Профессиональный Документы
Культура Документы
American
Version
Imperial Units
Lowest Temperature (F) at Which the Corrosion Rate Exceeds 5 mpy Table 4
2 - Type 317LMN
Welding This table shows the lowest temperature at which
the corrosion rate exceeds 5 mpy.
Type 317LMN is readily welded by a full range
All testing was done in accordance with the
of conventional welding procedures (except
requirements of the Materials Technology
oxyacetylene). To produce a fusion zone
Institute of the Chemical Process Industries
with corrosion resistance similar to that of the
(MTI).
base metal, filler metals of Alloy 625 (AWS
ERNiCrMo-3) or its lower carbon version,
Technical Support
ERNiCrMo-12, are commonly used with
317LMN. Outokumpu assists users and fabricators in the
selection, qualification, installation, operation,
Machinability and maintenance of Type 317LMN stainless steel.
Technical personnel, supported by the research
Type 317LMN is a very tough austenitic
laboratory of Outokumpu, can draw on years of
stainless steel subject to work hardening during
field experience with Type 317LMN to help you
deformation and is resistant to chip breaking.
make the technically and economically correct
The higher molybdenum and the nitrogen make
materials decision.
the chip abrasive, increasing tool wear. The best
Outokumpu is prepared to discuss individual
machining results are achieved with slower speeds,
applications and to provide data and experience as
heavier feeds, excellent lubrication, sharp tooling,
a basis for selection and application of
and powerful, rigid equipment.
Type 317LMN.
Outokumpu works closely with its distributors
Corrosion Performance of
to ensure timely availability of Type 317LMN
Stainless Steels
in the forms, sizes, and quantities required by
The corrosion resistance of Type 317LMN is the user. For assistance with technical questions
only slightly below that of the 904L stainless steel. and to obtain top quality Type 317LMN, call
Type 317LMN has a long service history in flue Outokumpu at 1-800-833-8703.
gas scrubbing applications but has not been fully
evaluated for chemical applications. However, it
would be conservative to use Table 4 as a guide,
considering 317LMN to be intermediate to 316L
and 904L.
Type 317LMN - 3
1089EN, Itasca, USA. August 2013.
Working towards forever.
We work with our customers and partners
to create long lasting solutions for the tools
of modern life and the worlds most critical problems:
clean energy, clean water and efficient infrastructure.
Because we believe in a world that lasts forever.
Information given in this brochure may be subject to alterations without notice. Care has been taken to ensure that the contents
of this publication are accurate but Outokumpu and its affiliated companies do not accept responsibility for errors or for
information which is found to be misleading. Suggestions for or descriptions of the end use or application of products or methods
of working are for information only and Outokumpu and its affiliated companies accept no liability in respect thereof. Before using
products supplied or manufactured by the company the customer should satisfy himself of their suitability.
2205 Code Plus Two is a trademark of Outokumpu Stainless, Inc.
254 SMO and 654 SMO are trademarks of Outokumpu Stainless.