Академический Документы
Профессиональный Документы
Культура Документы
Equipment
Adam’s Foam Gun
Bissell Steam Shot
Honda leaf blower
HD Bucket x2
Grit Guard bucket insert
3M Blue tape
Products Used
Adam’s All Purpose Cleaner
Adam’s Car Shampoo
Adam’s Vinyl, Rubber, and Tire Dressing
Adam’s Detail Spray
Adam’s Waterless Wash
Adam’s Green Wheel Cleaner
Adam’s Leather and Interior Cleaner
Adam’s Leather and Interior Conditioner
Adam’s Carpet and Upholstery Cleaner
Adam’s In and Out Spray
Adam’s Buttery Wax
Adam’s Swirl and Haze Remover
Adam’s Revive Polish
Invisible Glass Glass Cleaner
Armor All Acid Wheel Cleaner
Goo-Gone Cleaner Gel
Tanner’s Preserve Leather Cleaner
Maintenance – Weekly/ Biweekly
1. Spray Tire with All Purpose Cleaner (APC). Let dwell for a few minutes, then brush.
2. Spray Wheel and Calipers with Adam’s Green Wheel Cleaner (GWC). Let dwell for a few
minutes, and then agitate with brushes and microfiber gloves.
3. Rinse down.
4. Move to next wheel/tire.
5. After all 4 done, Bissell Steam Shot on hard/impossible to reach crevices and angles.
6. Foam Car down with Adam’s Car Shampoo, let dwell for a minute.
7. 2 bucket method with clean water grit guard and acrylic mitt agitate, rinsing mitt at least once
per panel. Pre-soak bug guts and dirt with Adam’s Waterless Car Wash if necessary.
8. Pressure wash soap off, then sheet water for dry.
9. Blow water out of crevices with leaf blower.
10. Spray Finish Adam’s Detail Spray on car before blot drying with waffle weave towel.
11. Sealant on wheels if necessary.
12. Adam’s Vinyl, Rubber, and Tire Dressing on tires and trim.
13. In and Out Spray on Hard to reach rubber.
14. Adam’s glass cleaner on glass.
15. Monthly/ Once per 2 months: Apply coat of Buttery Wax.
Engine - As Needed (Usually once or twice yearly) {Only perform on cold engines. Exceptions:
any foreign car made before 2000, Land Rovers, any cars with open engine bays.}
1. Cover all wires, alternator, HID Ballasts, etc. with aluminum foil
2. Place plastic bag over battery if exposed
3. Spray APC and let sit (do not let dry)
4. Scrub with Boar’s hair brush and q-tips for hard to reach areas
Captain Mobile Detailing
Tony Malouf
Chief Detailer
5. Lightly spray all areas treated with a solid pressured stream of water
6. AirServing
dry the
with leaf
Miami areablower, use waffle weave towels to dry any pooling water.
7. Once dry, remove all foil and treat engine with Adam’s VRT and IOS.
Variable rates and fleet discounts
Only the best quality products available
Phone: 786 252 0457
Email: t.mal44@gmail.com
Interior - As Needed (note: I have MB-Tex [Vinyl])
1. Clean MB-Tex with 303 Fabric/Vinyl Cleaner. (Or Leather with Leather Cleaner, Cloth Seats
with Carpet and Upholstery Cleaner)
2. Clean Plastics with Adam’s Detail Spray or Adam’s Leather and Interior Cleaner (If further
soiled).
3. Protect MB-Tex and Plastics with 303 Aerospace Protectant (Protect other Surfaces with
Leather and Interior Conditioner)
4. Vacuum Carpet with wet/dry vac
4. Treat carpets with Adam’s Carpet and Upholstery Cleaner and work in via brush.
5. Spray near boiling water on carpet if highly stained.
6. Extract with wet/dry vac
7. Protect with 303 High Tech Fabric Guard.
7. Dress Window switches and air vents with In and Out Spray