Академический Документы
Профессиональный Документы
Культура Документы
Rockets Engineer
Introduction
This isnt rocket science. Oh wait, yes it is; to that end we at ACME expect full adherence to
these instructions in order to ensure the safety of our astronauts and those who work to get them
off the ground. Rockets unlike other modes of transportation dont require any form of push
off to get them moving forward. The rockets we product at ACME are all self-contained,
meaning they dont require oxygen from the environment to provide fuel for energy.
Rockets work and operate using the law of conservation of linear momentum. This law states
that whenever two or more particles interact, the total momentum of the system remains
constant. Using fuel injection, we can achieve
speeds in excess of 6000 mph. A basic equation
for rocket thrust can be found below:
Material
Rocket Components:
Payload System
Guidance System
Structure System
Nose Cone
Frame
Fin
Propulsion System
Fuel
Oxidizer
Pumps
Nozzle
Step 2: Choose a central location within the launch site for the launch system.
Once an appropriate location has been chosen to host your base of operations, finding the
perfect spot to move your launch system to is essential. TIP: Any surface that is more than +5
or -5 degrees off a flat 180 will ruin your chances of successful atmospheric exit. Typically
in the center of a very large field will do just fine, given the previous conditions have been met.
Step 3: Prepare the rocket launch system (RLS).
After setting up the launch pad in a safe and ideal location you will want to prepare the
Rocket Launch System. The RLS consists of three separate buttons. Prepare, Ready, Take-off.
THE ORDER IS CRITICAL. Pressing any of these steps out of the correct sequence will lead
to a Very Large Kaboom! as Marvin the Martian would say. We do NOT want this.
This is what the eject button looks like. It can be found on the left side panel of your RLS.
If you run into any questions on the job--ASK. Better to look dumb then to lose a life.