cure polyurethane foam (OCF) used primarily USAGE DIRECTION : to seal, fill, fix & adhere the gap between All surfaces should be clean from door, window & wall. They are water proof, oil, greases, loose particles and CFC free, environment protective & are dust.Dry surfaces should be well flame retardant.OCF is the outcome of the sprayed or dampened with water. combionation of aerosol technique & Shake can vigorously for one minute polyurethane foam technique. before use. Screw plastic straw on can firmly, aim straw at gap then spray. TYPICAL PROPERTIES: When spray please pay attention to the speed. Fill vertical joints from the Base Polyurethane bottom up when half filled enough. When fill gaps in ceiling, uncured Flame retardancy B3 GRADE. foam may drop because of gravity, Density 15-30 kg/m3 please support properly after filling Temperature until foam cure and adhere to the gap. resistance 35 to 80 Foam is tack free after about 10 of cured foam minutes, can be cutted after 60 Tack free time 9-13 min minutes Cutting time 60 min Cured foam will turn yellow by direct Foam Yield 6 litters per 100ml. exposure to UV rays, so painting or Adhesive strength coating is recommended. >100KPA PVC to PVC Use a knife to smooth the cured foam Aluminium to and treat surface with cement, paint or >80KPA silicone. Aluminium Elongation at break 8-20% Advantages: Compression strength 35-100KPA Make use of convenience : No special at 10% compression training required easy to use like DIY. Shear Strength 22-50KPA Automatism spray : needless pouring, Water absorption 0.03% volume pressure in cans can put material into <0.035 gap. Thermo conductivity Kcal/m H Automatism expands: OCF can Tack free time: 9-13min expand by itself and fill in every gap. Cutting time: 60min Humidity cure : No need of cure Closed cells: 60-70% assistant, it can be cured by humidity Average burning time (s): 60 in air Average burning scope 25(mm) Automatism felt : No pre-treatment required for surface, it has good viscosity (especially wet surface).
PIDILITE INDUSTRIES LIMITED
Marketing Division: P.B. No. 17411, Andheri (East), Mumbai 400 059 (India). Page 1 Areas of Application:
Door and window installation : seal,
fill, fix and adhere the gap between door, window and wall. GENERAL INFORMATION Advertisement model : making of model, sand plate, repair of show Contents under pressure do not board. puncture or incinerate. Sound insulation and absorption : Keep away from open flame, heat, insulate and absorb sound as a and sunlight. sealant in speech room and broadcast studio. Do not use near fire, open flame or Daily maintenance : repair the hole, while smoking. gap, wall brick, earth brick Use in well ventilated area. Water proof and block leakage : mend Wear protective gloves & goggles the hole of water pipe and cloaca. while spraying. Packing and transportation, pack Store can in cool dry place, below valuable and fragile goods easily, time 50. saving, quick, shock and press resistance. After use empty out the container completely, crush to avoid refilling. SAFETY & PRECAUTIONS: Dispose crushed cans as per The container should be capped immediately applicable government regulations. after use to avoid exposure to atmosphere. Users are recommended to confirm compatibility of the product with For safe handling information on this product, application substrates. refer the Material Safety Data Sheet (MSDS). PACKING: 750ml aerosol can. SHELF LIFE: 9 months when stored at from date of DISCLAIMER: manufacturing in factory sealed container. We recommend that before using our product, the customer should make his own test to STORAGE determine the suitability of the product for his Store in cool & dark shaded place away from own purpose under his application conditions. As direct sunlight in tightly closed condition. the circumstances under which our product is stored, handled and used, are beyond our There is pressure of 5-6kg/sq.cm(25deg.c), control, we cannot assume any responsibility of hence to ensure that temperature wont their use/misuse by the user. exceed 50deg.c during storage & transportation to avoid explosion. Rev. 0.1/30/08/2012.