Вы находитесь на странице: 1из 5

1.

In a series resonant band-pass filter, a lower value of Q results in


a) a smaller bandwidth
b) a higher resonant frequency
c) a larger bandwidth
d) a higher impedance

2. The maximum output voltage of a certain low-pass filter is 15 V. The output voltage at the
critical frequency is
a) 0 V
b) 10 V
c) 10.60 V
d) 21.21V

3. The problem of passive filters is overcome by using


a) Analog filter
b) Active filter
c) LC filter
d) A combination of analog and digital filters

4. Ideal response of filter takes place in


a) Pass band and stop band frequency
b) Stop band frequency
c) Pass band frequency
d) None of the mentioned

5. What is an ideal value of attenuation for the frequencies in pass band especially for a cascade
configuration?

a) Zero
b) Unity
c) Infinity
d) Unpredictable

6. In an RL high-pass filter, the output is taken across the inductor and the output leads the input.

a) True

b) False

c) None of above

7. A circuit that rejects or stops frequencies over a narrow range but allow all frequencies above
and below to pass in the

a) high pass
b)Band pass
c) Reject filter
d) All pass filter
8. What is the kind of relationship between and ?
a)Many-to-one
b) One-to-many
c) One-to-one
d) Many-to-many
9. Which of the following is the backward design equation for a low pass-to-high pass
transformation?

10. Which of the following is a low pass-to-high pass transformation?


a) s / u
b) s u / s
c) s u.s
d) None of the mentioned
11. If s=+j and z=rej, then what is the condition on if r<1?
a) > 0
b) < 0
c) > 1
d) < 1
12. When a low-pass and a high-pass filter are cascaded to get a band-pass filter, the critical
frequency of the low-pass filter must be

a) equal to the critical frequency of the high-pass filter


b) less than the critical frequency of the high-pass filter
c) greater than the critical frequency of the high-pass filter
d) Both a) and c)

13. A state-variable filter consists of

(a) one op-amp with multiple-feedback paths


(b) a summing amplifier and two integrators
(c) a summing amplifier and two differentiators
(d) three Butterworth stages
14. When the gain of a filter is minimum at its center frequency, it is
(a) a band-pass filter
(b) a band-stop filter
(c) a notch filter
(d) answers (b) and (c)
15. What is the center frequeny of band pass filter using casecaded low and high pass filters

a)
b)
c)

16. Gain of multiple feedback filter

a)

b)

c)

17. Poles and zeros are arranged alternatively on negative real axis, then type of network is/are

a)LC network
b) RC
c)RL
d) both c and b
18. If an impulse response of a system is e-5t, what would be its transfer function?

a. 1/ s 5
b. 1/ s + 5
c. (s+1) / (s+5)
d. (s2 5s)/ (s-5)

19. For the transfer function given below, where does the zero of the system lie?

a. s = -1 & s = -1/4
b. s = -4 & s = -1
c. s = 1/5
d. s = -1/5

20. The expression of power (P1) at lower half power frequency is?
a) (I2maxR)/8
b) (I2maxR)/4
c) (I2maxR)/2
d) I2maxR
21 The expression for lower half power frequency is

a) (-R+(x2+4LC))/4L
b) (R-(x2+4LC))/4L
c) (R-(x2+4LC))/4L
d) (R+(x2+4LC))/4L

22. If a series circuit contains resistor and capacitor, the expression for quality factor is?

a) C
b) RC
c) C
d) 1/RC

23. Classification of Pass Band and Stop Band

a) = + j
b) = + j
c) = + j
d) = + j

24. The coefficients of numerator polynomial and the denominator polynomial in a transfer function
must be?

a) real
b) complex
c) at least one real coefficient
d) at least one complex coefficient

25 .The s-domain equivalent of the inductor reduces to an inductor with impedance?

a)L
b) sL
c) s2L
d) s3L

26. in rc series circuit find the value of current

a)(V/R)/(s+1/RC)
b) (V/C)/(s+1/R)
c) (V/C)/(s+1/RC)
d) (V/R)/(s+1/R)

27. in low pass to high pass frequency transformation, divide the frequency axis of high pass filter
by

a) pass band corner frequency

b) stop band corner frequency


c) Both a) and b)

d) none of these

28. to transform low psssfunction to band pass function equation is

a) = X( )
b) = 1/X( )

c) = X()

d) = X( )/js

29. An RC high-pass filter consists of an 820 resistor. What is the value of C so that Xc is
ten times less than R at an input frequency of 12 kHz?
a)81F

b)161 F

c)0.161 F

d)220 F

30.A parallel resonant band-pass filter consists of a 90 resistor in series with a parallel
network made up of a 60 mH coil and a 0.02 F capacitor. The output is taken across the
capacitor/coil. The coil winding has a resistance of 20 . What is the center frequency of
the filter?

459 Hz

4,591 Hz

999 Hz

2,176 Hz

Вам также может понравиться