Академический Документы
Профессиональный Документы
Культура Документы
A: 64
B: 32
C: 128
D: 16
10: How many intelligent devices can be daisy-chained together from a standard SCSI
controller?
A: Seven (8 if you include the adapter card)
B: Nine
C: Ten
D: Six
12: The design of the ISA bus only allows for support of 16 MB of memory. If that is the
case, how can a computer support 64MB of memory?
A: By page swapping
B: By Virtual Increasing
C: By Adding an card
18: You are testing a household electrical outlet. If you test the ground & neutral wires,
you should get what reading?
A: 0
B: 1
C: 3
D: 2
21: When configuring a new network interface card for installation, what would be a
valid I/O address?
A: 360
B: 180
C: 270
D: 90
A: +12
B: -12
C: +5
D: -5
E: All the above
24 .What is IP The Internet Protocol (IP) is a data-oriented protocol used for
communicating data across a packet-switched internetwork.
25. What is TCP/IP? The Transmission Control Protocol (TCP) is a virtual circuit
protocol that is one of the core protocols of the Internet protocol suite, often simply
referred to as TCP/IP. Using TCP, applications on networked hosts can create
connections to one another, over which they can exchange streams of data using
Stream Sockets. The protocol guarantees reliable and in-order delivery of data from
sender to receiver. TCP also distinguishes data for multiple connections by
concurrent applications (e.g., Web server and e-mail server) running on the same
host.
26. What is ARP? In Computer Nwk, the Address Resolution Protocol (ARP) is the
method for finding a host's hardware address when only its Network Layer address is
known
27. What is IPsec? IPsec (IP security) is a suite of protocols for securing Internet
Protocol (IP) communications by authenticating and/or encrypting each IP packet in
a data stream. IPsec also includes protocols for cryptographic key establishment.
28. Which of the following volume types provide fault tolerance? [ Select 2].
Simple Volume
Striped volume
Mirrored volume
RAID-5 volume
29. You have recently changed your video driver. However, you find that the driver is not
OK. Which option in the Advanced Options menu is most suitable so that you can test
and re-install the new video driver if necessary?
Safe Mode with Networking
Safe Mode with Command prompt
Enable Boot Logging
Enable VGA Mode
30. While installing Windows 2000 over the network, you are prompted to supply the
domain controller, username and password. However, though you have supplied the
information, your computer could not join the domain. What would have been the
problem? [Select 2].
31. You can’t join a domain during installation of Windows 2000, you need to join at a
later time
The domain controller may not be up and running
The username and password may not be correct
The network card may be faulty
32. You want to create new local user on your Windows 2000 Professional computer.
Which tool can you use?
Disk Management
Computer Management
Services
Scheduled Tasks
33. You want to add Traditional Chinese language support. Which tool should you use to
support multiple languages on your Windows 2000 computer?
Accessibility Options
Regional Options
Add/ Remove Programs
Sounds and Multimedia
34.Which are the two means that images on a Remote Installation Services (RIS) Server
can be configured with? [Select 2].
Through the use of a CD-based image that contains the Windows 2000 Professional
operating system.
Through the use of back-up tape drive that contains the Windows 2000 Professional
operating system
A Remote Installation Preparation (RIPrep) image that contain the Windows 2000
Professional operating system and applications.
Through the use of Sysprep utility
35. Your Windows 2000 Professional computer is experiencing slow performance when
you run several applications. The computer has the following configuration:
36. Which of the following views are available in Windows 2000 System Monitor?
[Select 3].
Histogram View
Chart View
Report View
Multi View
37 .Joe is a member of Sales group and Support group. The following NTFS permissions
are assigned to these groups to a folder:
38. You have installed Windows 2000 Professional on your computer. However, when
you try to connect to the Internet. You suspect that the TCP/IP stack was not properly
installed. Which of the following can you use to check whether the TCP/IP stack is
installed properly on the Windows 2000 Computer ? [Select 2].
Ipconfig
Ping Localhost
Ping 127.0.0.1
Tracert
39 .A user has "Write" NTFS permissions to a file on an NTFS volume. You have have
observed that the file "attribute" is set to "Read". What will be the resulting permission
applicable to the user?
Write
Read
No Access
None
40. You are planning to buy a computer. You also want to install Windows 2000
Professional on this computer. What are the minimum hardware requirements to install
this operating system?
Pentium 120 MHz / 16MB RAM/ 320MB hard disk space
Pentium 133 MHz / 32 MB RAM/ 500MB hard disk space
Pentium 133 MHz/ 64MB RAM/ 640MB hard disk space
Pentium II / 128 MB Ram / 1GB hard disk space
41. Sally has installed a special application on her Windows 2000 Professional computer.
Whenever, she accesses a file with .nic extension, the file should open the special
application. How can she configure her computer so that, a file with .nic extension
automatically open the special application?
Control panel -> System -> General, configure file options
Windows Explorer -> View -> File Types and configure appropriately.
Control panel -> System -> Advanced and configure the file extension
Windows Explorer -> Tools -> Folder Options -> File Types and configure appropriately
46. Jane is using Sysprep to automate the installation of Windows 2000 Professional on
65 computers. All the computers are HAL compatible with the master computer running
Sysprep. However, they have different Modem cards, and sound cards. She also want to
fully automate the installation process. However, when Jane tries to install the duplicated
disk on target computer, she is not able to proceed with the installation process. She has
copied setupc1.exe and sysprep.exe to the folder C:\sysprep. What you need to do?
[Select 2].
Copy sysprep.inf file to C:\sysprep folder
Use -pnp switch with the Sysprep.exe command
Copy sysprep.ini file to C:\sysprep folder
Use –reboot switch with the Sysprep.exe command
47 . You have some files in a folder called “Myfiles” on a server “Server01”. You want
to map this share to a network drive “Z” on your computer. Which command does this?
map Z: \\Server01\Myfiles
net use Z: \\Server01\Myfiles
net map Z: \\Server01\Myfiles
use Z: \\Server01\Myfiles
49. What are the recommended minimum hardware requirements for installing
Windows 2000 Server operating system?
A. Pentium 133MHz processor, 256MB RAM, 1GB available hard disk space
C. Pentium 100MHz processor, 32MB RAM, 250MB available hard disk space
D. Pentium III processor, 256MB RAM, 2GB available hard disk space
50. Robert wants to install Windows 2000 Server on 15 new computers over the
network. All the computers have identical hardware configuration. Which files are
required for automating the installation process? [Choose 2 correct answers].
A. HOSTS file
B. Answer file.
C. UDF file
D. LDF file
51. Jim intends to install Windows 2000 Server Operating System on 12 computers.
The computers are connected to 12 departments of his company. All computers have
identical hardware configuration. He wants to install Server Operating system over
the network, completely unattended. For this purpose, which are the three switches
that he needs to specify along with the Winnt command? [Choose 3 correct choices].
A. /s
B. /udf
C. /cmpcons
D. /u
B. Use sysprep tool to prepare the hard disk for disk duplication
C. There is no provision to duplicate hard disk using Windows 2000 Server tools.
53. Reed is installing Windows 2000 Server software on his computer. He needs to
install a third party SCSI driver available on a floppy disk, during the installation
process. During which phase of Windows 2000 Server installation can he supply the
SCSI drivers specific to his computer?
D. Windows 2000 Server does not allow third party SCSI drivers.
54. Paul is asked to upgrade the existing Windows NT4 server network to Windows
2000 Server network. He has 5 NT Servers, of which 2 are BDCs, 1 is a PDC, 250
Windows 2000 Professional computers. He has another new computer that he wants
to install as Windows 2000 Domain Controller. What is the required sequence of
steps installation of his new PC as Windows 2000 Domain Controller?
A. Install Windows 2000 Server using CD. Configure the computer as Domain
Controller.
B. Install Windows NT4 make it a BDC (Backup Domain Controller). Then, promote
the computer as PDC. Now, upgrade to Windows 2000 Server and configure the
computer as Domain Controller.
C. Do over the network installation for Windows 2000 Server and configure as
Domain Controller.
D. Install Windows NT4 as member server. Now, upgrade to Windows 2000 Server
and configure the computer as Domain Controller.
A: TCP / IP
B: SMTP
C: POP3
D: DNS
A: 1352
B: 1494
C: 8080
D: 389