Академический Документы
Профессиональный Документы
Культура Документы
SET B
Name 1: . Name 2: .
Phone number . Phone number .
AAKAAR ID . AAKAAR ID .
2. Addition of Carbon to steel ___________ its malleability and its ductility (1)
4. The effective length of a compression member of length L held in position and restrained in direction at one end
and effectively restrained in direction but not held in position at the other end, is _________ (1)
5. The reaction time for calculation of stopping distance may be assumed as (1)
a. 1.0 sec
b. 1.5 sec
c. 2.0 sec
d. 2.5 sec
6. In the case of stratified soil layers, the best equation that can be adopted for computing the pressure
distribution is (1)
a. Prandtl's
b. Skempton's
c. Westergaard's
d. Boussinesq's
7. The efficiency of the brakes of a vehicle depends upon (1)
a. Condition of road surface
b. Speed of Vehicle
c. Perception of Driver
d. Condition of Tires
i. a and b
ii. a, c and d
iii. a, b and d
iv. None of the above
8. Identify the brickwork pattern shown in the figure (1)
9. The ability of concrete to retain its volume after it has set is (1)
a. Hardness
b. Soundness
c. Consistency
10. Weirs constructed on permeable foundation are likely to fail due to (1)
a. Crushing
b. Sliding
c. Piping
d. None of the above
11. For a certain soil, value of porosity remains between 0 and 1, what can be the value of void ratio for the above
mentioned soil?(E) (1)
a. e=0
b. e>1
c. 0<e<1
d. e>0
17. In a beam of length L, four possible influence line diagrams for shear force at a section located at a distance of
L/4 from the left end support are shown below. The correct influence line diagram is (1)
a.
c.
b.
d.
18. (2)
CASE 1 CASE 2
In the given two cases shown above, active earth pressure is maximum for case . and passive earth
pressure is max for case .
19. According to IS 456:2000, total water soluble sulphate content of concrete should not exceed what percentage by
mass of cement mixture (Not for supersulphated cement) (1)
a. 0.5
b. 1
c. 2
d. 4