Академический Документы
Профессиональный Документы
Культура Документы
F
D
B
Instructions are for the tall short stool), mark the same edge of each leg and similarly off each outside corner to
stool. We used seasoned angle and cut a leg. Repeat mark 19mm from the outer remove the sharp edge. Glue
oregon, dressed to standard this cut for other three legs. edge 150mm from the bottom and nail slats to stool, starting
sizes by the timber yard. You 2 Mark 45mm across bottom of each leg (70mm on short with the centre slat.
will need one 4.2m length of of each leg and 400mm up stool). Glue and screw top 7 Plug counterbored screw
90 x 19mm and two 1.8m the inside edge. (On the short spreader in place followed holes with glued-in dowelling.
lengths, one 70 x 19mm stool the measurements are by bottom spreader, leaving Cut flush with timber surface
and the other 40 x 19mm, 45 and 200mm.) Join marks space for the rails. Make and sand smooth. Sand all
with a little to spare. Check and cut to form a taper on second set of legs then stand surfaces smooth and finish
components against actual base of leg. Repeat for other them on edge. with a hard-wearing
unit as it is being built. legs. Smooth saw cuts with 4 Cut top and bottom rails polyurethane coating.
All joints are glued with a plane. Always take thin (D, E) to length and glue and
high strength wood glue and shavings and plane down the nail to the recesses in the leg To make a second, smaller
screwed with recessed screw slope so you are working with assemblies left from step 3. stool as a stepping platform,
holes to be filled later. the grain. Cutting up the slope Add a screw from the leg into most of the dimensions
will cause the plane to dig in end of each rail. Stand the except the legs and the
Heres how and leave chatter marks. stool on its legs to check that lower spreader are the same
1 Set a sliding bevel to an 3 Lay pair of legs on the table it stands perfectly. Adjust if and the construction is the
85 angle from a protractor and cut the top and bottom necessary. same as above.
to give a 5 splay to the legs spreaders (B, C). The bottom 5 Cut four corner blocks (F)
(A). Keep this bevel setting spreader is cut with the same with a 45 mitre at each end
as it will be needed later. 5 angle at both ends as the and screw into the corner of
Mark angle on the length of legs so the bottom side rails the top spreaders and rails.
90 x 19mm timber and cut. follow splay of the legs. Mark 6 Cut the three seat slats (G)
Measure 630mm (330mm for 19mm in from the top outer and trim a small 45 triangle
http://www.bhg.com.au