Академический Документы
Профессиональный Документы
Культура Документы
TEST I:
Directions: Choose the letter of the correct answer. Write your answer on the separate
sheet of paper.
MULTIPLE CHOICE:
1. These tools are made of hardened metal and use to loosen and tighten screws
a. cutter b. Screw drivers c. Long nose d. hammers
2. Type of screw driver resembles a negative sign (-).
a. Philip screw driver b. Flat Screw driver c. Hex driver d. Allen screw
3. This has a cross tip resembling positive (+) sign. Used to drive screws with cross
slot heads
a. Flat screw b. Philip screw c. Hex driver d. Allen screw
4. This is used for gripping, holding, cutting and they are usually used by linemen
in doing heavy task.
a. Diagonal side cutter b. Combination pliers c. Wire stripper d. Long nose
5. This is used for cutting and holding. This can reach tight space and small
opening where other pliers can’t reach.
a. Diagonal side cutter b. Combination pliers c. Wire stripper d. Long nose
6. Electrical tools used for removing the insulation of medium wires ranging from
#10 to #16 AWG.
a. Side cutter b. Wire stripper c. Combination pliers d. Long nose
7. This type of pliers is used for cutting wires.
a. Diagonal side cutter b. Combination pliers c. Wire stripper d. Long nose
8. Protective device that automatically blows and cut the current when there is
short circuits occur.
a. Fuse b. Switch c. Male plug d. lamp holder
9. A circuit contained 10Ω resistor and powered from a 220V source, what is the
total current flowing in the circuit?
a. 2200A b. 22A c. .22A d. .0022A
10. A circuit contained 30Ω resistor and powered from a 10V source, what is the total
current flowing in the circuit?
a. .33A b. 67A c. 40A d. 60A
Test II.
Direction: Determine and trouble shoot the appliances. identify the possible problem
and cause. then, recommend an action to be done. Choose your answer on the box
provided below.