Академический Документы
Профессиональный Документы
Культура Документы
PROJECT REPORT
On
BACHELOR OF TECHNOLOGY
Degree from
In
PAVAN KUMAR
RISHIKESH MECH
DEEPAK NAGARKOTI
SIDDHARTH KUMAR
DEPARTMENT OF INDUSTRIAL
[i]
CERTIFICATE
(Project Guide)
[ii]
CANDIDATE’S DECLARATION
We hereby declare that the work which is being presented in this Major Project Entitled,
“CONVEYOR SYSTEM” submitted to DEHRADUN INSTITUTE OF TECHNOLOGY,
DEHRADUN in the partial fulfillment of the requirement for the award of the degree of
BACHELOR OF TECHNOLOGY in INDUSTRIAL & PRODUCTION ENGINEERING,
is an authentic record of our own work carried out from August, 2013 to April, 2014 under the
supervision of Asst. Prof VIJAY KUMAR in IPE DEPARTMENT, DIT, DEHRADUN.
The matter embodied in this project has not been submitted by us for the award of any other
degree.
Place:
Date
This is to certify that the above statement made by the candidates is correct to the best of my
knowledge.
[iii]
List of figure
Fig 1.1: parts of conveyor system
Fig 2.2.4: layout of a roller chain: 1.Outer plate, 2.Inner plate, 3.Pin, 4.Bushing, 5.Roller
Fig 2.2.5: an example of two 'ghost' sprockets tensioning a triplex roller chain system
Fig 2.3.1(a): when a current passes through a coil of wire, a magnetic field is produced
Fig 2.3.1(b): a coil of wire through a magnetic field, a voltage will be induce
Fig 2.3.2(c): a current carrying conductor in the air gap of two magnets
Fig2.3.2(d): the conductor will be pushed from stronger to the weaker field
Fig2.3.2(d): the current from the DC power source flows from the positive lead
Fig 2.4.6: alternator mounted on an automobile engine with a serpentine belt pulley
[iv]
TABLES OF CONTENT
TOPICS Page No
Certificate i
Declaration ii
Acknowledgement iii
Table of figure iv
Table of content v
CHAPTER 1 AN INTRODUCTION 1
2.4 ALTRNATOR 19
2.5 WORMGEAR 29
2.6 BATTERY 32
3.2 CALCULATIONS 43
CHAPTER 4 CONCLUSION 48
REFERENCES 49
[v]