Академический Документы
Профессиональный Документы
Культура Документы
INSTRUCTIONS-
1.NUMBER OF QUESTIONS 25
2.HAS A TIME LIMIT OF 15 MINUTES
3.HAS A PASS MARKS OF 30%
4.QUESTIONS PER PAGE 1
5.EACH QUESTIONS HAS 1 MARKS
6.NEGATIVE MARKING FOR EACH QUESTIONS IS 0.25
7.WILL ALLOW TO YOU GO BACK ,SKIP AND CHANGE YOUR ANSWERS
8.WILL ALLOW TO YOU PRINT OUT YOUR RESULT AND CERTIFICATE
9.WILL ALLOW TO YOU PRINT OUT YOURS RESPONSE SHEET WITH
CORRECT ANSWER KEY AND EXPLANATION.
.
.
Max Time Al lowed: 15 mi n
B. Absolute stability
C. Frequency response
D. Relative stability
B. sensitivity
C. system stability
D. gain
B. current
C. capacitance
D. reciprocal of capacitance
B. displacement
C. mass
D. momentum
B. Nyquist Criterion
C. Phase-plane representation
D. Quasi linearization
B. rises quickly
C. rises slowly
D. decays quickly
1 of 4
Q.8) Velocity error constant of a system is measured when the input to the system is unit _______
function.
A. ramp
B. step
C. parabolic
D. impulse
B. Lead-lag compensation
C. Lead-compensation
Q.11) By which of the following the system response can be tested better ?
A. Exponentially decaying signal
B. sensor
C. amplifier
D. comparator
Q.13) .In an automatic control system which of the following elements is not used ?
A. Error detector
B. Sensor
B. sensor
C. comparator
D. amplifier
B. zero, constant
C. constant, constant
D. constant, infinity
B. infinity
C. unity
D. zero
Q.17) Static error co-efficients are used as a measure of the effectiveness of closed loop systems for
specified ________ input signal.
A. velocity
B. acceleration
C. position
D. all of these
2 of 4
Q.18) A conditionally stable system exhibits poor stability at
A. none of the these
B. low frequencies
C. Linear systems
Q.20) Which of the following is the best method for determining the stability and transient response ?
A. Nyquist plot
B. none of these
C. Root locus
D. Bode plot
Q.21) In order to increase the damping of a badly underdamped system which of following
compensators may be used ?
A. Both phage lead and phage lag
C. Phase-lag
D. Phase-lead
Q.22) .If a step function is applied to the input of a system and the output remains below a certain level
for all the time, the system is
A. always unstable
B. stable
D. unstable
B. two poles
C. no net pole
D. simple pole
Q.24) The frequency and time domain are related through which of the following?
A. Fourier Integral
D. Laplace Transform
B. Analogous table
3 of 4
Answer Key
Q.1) The output for any given input
Q.2) Relative stability
Q.3) system stability
Q.4) reciprocal of capacitance
Q.5) mass
Q.6) Nyquist Criterion
Q.7) decays quickly
Q.8) ramp
Q.9) Lag-compensation
Q.10) smaller damping ratio
Q.11) Unit impulse input signal
Q.12) comparator
Q.13) Oscillator Oscillator oscillator
Q.14) final control element
Q.15) zero, constant
Q.16) infinity
Q.17) all of these
Q.18) reduced values of open loop gain
Q.19) Linear and time-in variant systems
Q.20) Root locus
Q.21) Phase-lead
Q.22) not necessarily stable
Q.23) two poles
Q.24) Laplace Transform and Fourier Integral
Q.25) Signal flow graph
4 of 4