Академический Документы
Профессиональный Документы
Культура Документы
M agniw ork
Table ofContents
Introduction ...................................................... 8
1. H ow to Reduce Energy Consumption .......... 11
Stand By Energy Consumption Charts: .......... 14
2. H ow D oes G rid Systems W ork..................... 19
Portable Pow er Source System ..................... 20
G rid-Intertied Pow er Source System ............. 21
G rid-intertied solar pow er system w ith battery
backup ........................................................... 22
O ffG rid Pow er System .................................. 23
The U nits ofthe System ................................ 24
3. From W here to G et the M aterials ............... 29
4. Equipment................................................... 31
5. H ow the G enerator Functions ..................... 33
Chapter: Introduction
6. Construction ................................................ 36
7. G allery ......................................................... 43
2
M agniw ork
Chapter: Introduction
3
M agniw ork
DISCLAIMER
Chapter: Introduction
4
M agniw ork
5
Chapter: Introduction
M agniw ork
Chapter: Introduction
6
M agniw ork
7
Chapter: Introduction
M agniw ork
Introduction
Solar energy i.e the Energy from the sun is the most
abundant energy available on our planet. W e should take
advantage of this energy. By implementing a system w hich
Chapter: Introduction
8
M agniw ork
Chapter: Introduction
10
M agniw ork
11
M agniw ork
Figure 1
12
M agniw ork
13
M agniw ork
Chapter:
14
M agniw ork
Chapter:
15
M agniw ork
Chapter:
16
M agniw ork
18
M agniw ork
19
M agniw ork
1. Pow er Source
2. Charge Controller
3. Battery
4. Inverter
Chapter: H ow D oes G rid Systems W ork
5. H ousehold
20
M agniw ork
1. Pow er Source
2. Array DC disconnect
3. Inverter
4. AC Breaker panel
Chapter: H ow D oes G rid Systems W ork
5. H ousehold
6. Kilowatt per hour meter
7. Grid
21
M agniw ork
1. Pow er Source
2. Array DC disconnect
3. Charge Controller
4. Deep cycle battery
Chapter: H ow D oes G rid Systems W ork
5. System meter
6. Main DC disconnect
7. Inverter
8. AC Breaker panel
9. Kilowatt per hour meter
10. Grid
11. Household
22
M agniw ork
1. Pow er Source
2. Array DC disconnect
3. Charge Controller
Chapter: H ow D oes G rid Systems W ork
23
M agniw ork
Array D C D isconnect:
new battery, you can get on the cheap from old golf cart
or forklift.
M ain D C D isconnect:
Inverter:
25
M agniw ork
AC Breaker Panel:
Chapter: H ow D oes G rid Systems W ork
26
M agniw ork
G rid:
H ousehold:
27
M agniw ork
28
M agniw ork
Com ponents:
http://w w w .maplin.co.uk/
http://w w w .radioshack.com/
M agnets:
http://e-magnetsuk.com/
Chapter: From W here to G et the M aterials
29
M agniw ork
Com ponents:
http://w w w .allelectronics.com/
http://w w w .radioshack.com/
M agnets:
http://w w w .magnets4less.com/
30
M agniw ork
4. Equipm ent
M ultim eter:
31
M agniw ork
Soldering Iron:
32
M agniw ork
33
M agniw ork
34
M agniw ork
35
M agniw ork
6. Construction
Chapter: Construction
36
M agniw ork
W hen place into the bent w ires they w ill be snug fit and
make a firm contact. After that you w ill ne 12 pieces of
37
M agniw ork
38
M agniw ork
Six slots are than cut at the top of a 0.30 thick copper
tube w hich is 2” long by 2½ ” inside diameter. These slots
are 5/8” w ide by 1/32” deep spaced at 60 degrees apart.
Chapter: Construction
Then you repeat the same process just at the bottom but
you should keep them in line w ith the upper slots.
39
M agniw ork
40
M agniw ork
41
M agniw ork
#2, w hich is top layer to top layer. This pattern then has
start of coil 2 (bottom layer) going to start of coil 3 (also
bottom layer). W hen the copper tube w ith the coils is
placed around the rotor,the distance from any magnet to
any coil must be identical. If it measures different, acrylic
holding shapes can be bolted to the aluminum base,
protruding upw ard, and thus push the copper tube in the
direction needed to maintain the spacing as stated. The
rotational direction is clock w ise w hen view ing from top
dow n. Then you should make Acrylic dome for protection
against outside elements.
42
M agniw ork
7. Gallery
W iring D iagram
Chapter: G allery
43
M agniw ork
Rotor View
Chapter: G allery
44
M agniw ork
Chapter:
45
M agniw ork
46
M agniw ork
47
M agniw ork
48
M agniw ork
A: N O
Chapter: Frequently Asked Q uestions (FAQ )
A: N o,it w on't.
49
M agniw ork
Q: The coils that are w ound w ith the stated turns do not
add up to the specified sizes,w hy not?
50
M agniw ork
51
M agniw ork
52
M agniw ork
53
M agniw ork
54
M agniw ork
55
M agniw ork
56
M agniw ork
57