Вы находитесь на странице: 1из 3

Experiment # 1:

To observe the working of a single phase power system and its theoretical
variation through per unit analysis

Pre lab reading assignment:

Article 1.10 and 1.11 from ‘power system analysis” by John J. grainger and
William D.stevenson.
Article 3.3 from ‘power system analysis & Design” by Glover and Sarma

One Line Diagram with Parameters:

Figure:
Power System Analysis lab manual, Reg #:

Procedure:

1. Start Matlab and go to Start -> Simulink -> SimPower Systems -> Block Library.
2. Open a new file by clicking file ->new->model or pressing ctrl +n.
3. Take Voltmeter and Multimeter from measurements section of block library.
4. Take Transformer, RLC branch and ground node from Elements section.
5. Take AC voltage Source from sources section.
6. Also paste the ‘power gui’ from the block library SimPower Systems in your
file.
7. You may also connect Scope with voltmeters and ammeter. Scope can be
taken from Simulink -> Commonly Used Blocks.
8. Make the connections as shown in the figure.
9. Set the values of various blocks as instructed below.
10. Run the Simulation
11. Open powergui window and observe values of voltages and currents in
‘Steady State Voltages and currents’ section.

12. Enter the values observed in step 2 in observations given below.

Values of Different parameters:

Source: Voltage peak =√2 × 220 , Frequency = 50 Hz measurement: voltage

T1: 30kVA, 240/480V, R=0p.u., X=0.1p.u. measurement: all voltages and currents

T2: 20kVA, 460/115V, R=0p.u., X=0.1p.u. measurement: all voltages and currents

Transmission Line= X = 2 measurement: branch voltage and current

Load (also made from series RLC branch)= 0.9+0.2j measurement: branch voltage
and current

Touqeer A Raza EED, MNS UET, Multan


2
Power System Analysis lab manual, Reg #:

Power Gui Block:

Check ‘Discretize Electrical model’ & set Sample time = .0002

Observation table

Set1:

Vsource = T1 primary Voltage= T1 secondary voltage=

T2 primary voltage = T2 secondary voltage= Vline =

Vload = Isource= Iline=

Iload=

Task

Solve the above system using per unit analysis, calculate and compare the values
measured in observation sets.

(Attach assignment with the manual and submit it in lab)

Touqeer A Raza EED, MNS UET, Multan


3

Вам также может понравиться