Академический Документы
Профессиональный Документы
Культура Документы
My task is to draw two filters in PSpice and do simulations to get the frequency responses (both
magnitude and phase responses).
1. Start PSpice
2. Start a new project by File -> New -> Project, and enter your project name and location. Make sure
you choose the Analog or Mixed A/D, or you will not be able to do simulation.
You can choose your R, C, L from the analog.olb library in the \Library\PSpice folder:
2) To place ground, click Place -> Ground, then add source.olb in \Library\PSpice folder,
3) To place the voltage source, again Place -> Part and choose VAC in source.olb.
4) Draw wires and change parameters of parts, then I get the schematic below:
3) In “General Settings “set the Start frequency as 10(Hz) and End frequency as 1M(Hz), and 10
points per decade (if choosing logarithmic sweep type).
4) Then I can do simulation by click PSpice -> Run. Then the PSpice AD window will pop out.
This is the place I get the frequency response traces.