Академический Документы
Профессиональный Документы
Культура Документы
mk:@MSITStore:C:\SProV8i%20SS5\STAAD\Help\International_Codes_2007.chm:... 11-10-2017
9E.4 Design Parameters Page 2 of 4
1.0
BEAM 0.0 = design at ends and those locations
specified by the SECTION command.
0 = Minimum detail
1 = Intermediate detail level
2 = Maximum detail
DJ2 End Joint of Joint No. denoting end point for calculation
member of "Deflection Length".
mk:@MSITStore:C:\SProV8i%20SS5\STAAD\Help\International_Codes_2007.chm:... 11-10-2017
9E.4 Design Parameters Page 3 of 4
LST 0
Defines the number of longitudinal stiffeners
used:
0 = No longitudinal stiffener
1 = Longitudinal stiffener is
provided at 0.2D of web from the
compression flange
2 = Longitudinal stiffeners are
provided at 0.2D and 0.5D of the web
from the compression flange
mk:@MSITStore:C:\SProV8i%20SS5\STAAD\Help\International_Codes_2007.chm:... 11-10-2017
9E.4 Design Parameters Page 4 of 4
PROFILE None
Used to search for the lightest section for the
profile(s) specified for member selection.
STP 1
Specifies the section type per Table 2 and
Table 10:
0 = Minimum detail
1 = Intermediate detail level
2 = Maximum detail
TSP 0
Spacing of transverse stiffeners.
TST 0
Used to control transverse stiffeners in
design:
0 = No Transverse Stiffener is
provided
1 = Transverse Stiffener is provided
mk:@MSITStore:C:\SProV8i%20SS5\STAAD\Help\International_Codes_2007.chm:... 11-10-2017