Академический Документы
Профессиональный Документы
Культура Документы
the relay settings to be implemented in the ETAP software for the relay coordination.
For the overcurrent relay coordination, the single line diagram of the System will be
obtained from Customer.
The information on the type of relay used, location of the relays, numbers of relays installed
and the parameters for relay will be also acquired from customer.
The system will be modelled in the ETAP software using the data obtained from the
Customer.
For the protection setting, three phase short circuit and single phase to ground fault will be
performed in the software to obtain the fault current level.
The maximum and minimum fault current (three phase and single phase) are segregated
from short circuit analysis.
Based on the fault current theoretical calculations are performed for OC/EF Protection.
The theoretical values are incorporate in ETAP to check the co-ordination curve and final
corrections are made on calculation document.
Analysing the time grading between upstream and downstream protection devices and
tripping sequence also performed using ETAP.
The theoretical calculation for Unit Protection also done in document.
Preparing the Report including the settings and coordination curves in PDF format.
Sending the report to the customer.