Вы находитесь на странице: 1из 37

Manual Change History Page 1 of 37

Manual Change History


(4021560) ISX CM871 and ISM CM876 Electronic Control System Troubleshooting and Repair Manual
Procedure
Date Section Procedure Title Update Reason
Number
4021560-
Not Available Front Table of Contents
toc
Section i -
12-Mar-2002 99-204-004 Symbols
Introduction
Section i -
12-Mar-2002 99-204-005 Illustrations
Introduction
Section 19 -
Electronic Remote Accelerator
12-Mar-2002 99-019-333
Engine Controls Switch
- Group 19
Section 19 -
Electronic Engine Torque Limit
12-Mar-2002 99-019-335
Engine Controls Control Switch
- Group 19
Section 19 -
Electronic Component Connector
12-Mar-2002 99-019-361
Engine Controls and Pin Inspection
- Group 19
Section 19 -
Electronic
12-Mar-2002 99-019-380 Fan Control Switch
Engine Controls
- Group 19
Section 19 -
Electronic Maximum Engine Speed
12-Mar-2002 99-019-382
Engine Controls Switch
- Group 19
Section TS -
Troubleshooting
03-Apr-2002 Troubleshooting 99-t00-002
Symptoms Charts
Symptoms
Section 19 -
Electronic
22-Jan-2003 99-019-052 Idle Adjust Switch
Engine Controls
- Group 19
Section 19 -
Electronic Accelerator Interlock
22-Jan-2003 99-019-264
Engine Controls Switch
- Group 19
Section 19 -
Cruise Control or PTO
Electronic
04-Feb-2003 99-019-023 Set/Resume Select
Engine Controls
Switch
- Group 19
Section 19 -
Electronic Clutch Pedal Position
03-Apr-2003 99-019-009
Engine Controls Switch
- Group 19
Section 19 -
Electronic Cruise Control or PTO
03-Apr-2003 99-019-021
Engine Controls ON/OFF Switch
- Group 19
Section 19 -
Electronic Diagnostic Test Mode
03-Apr-2003 99-019-027
Engine Controls Switch
- Group 19

03-Apr-2003 Section 19 - 99-019-046 Fault Lamp


Electronic

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 2 of 37

Engine Controls
- Group 19
Section 19 -
Electronic
03-Apr-2003 99-019-054 Idle Validation Switch
Engine Controls
- Group 19
Section 19 -
Electronic Accelerator or Lever
03-Apr-2003 99-019-085
Engine Controls Pedal Position Sensor
- Group 19
Section 19 -
Electronic Brake Pedal Position
03-Apr-2003 99-019-088
Engine Controls Switch
- Group 19
Section 19 -
Electronic
03-Apr-2003 99-019-197 Ring Terminal
Engine Controls
- Group 19
Section 19 -
Electronic
03-Apr-2003 99-019-198 Fuse, Harness, In-line
Engine Controls
- Group 19
Section 19 -
Electronic
03-Apr-2003 99-019-199 Connector, Butt Splice
Engine Controls
- Group 19
Section 19 -
Electronic Metripack Connector
03-Apr-2003 99-019-202
Engine Controls Series
- Group 19
Section 19 -
Electronic
03-Apr-2003 99-019-203 Amp Connector Series
Engine Controls
- Group 19
Section 19 -
Electronic Deutsch™ DRC
03-Apr-2003 99-019-204
Engine Controls Connector Series
- Group 19
Section 19 -
Electronic Deutsch™ DTM and
03-Apr-2003 99-019-206
Engine Controls DTP Connector Series
- Group 19
Section 19 -
Electronic ITT Cannon Connector
03-Apr-2003 99-019-209
Engine Controls Series
- Group 19
Section 19 -
Electronic
08-Apr-2003 99-019-080 Remote PTO Switch
Engine Controls
- Group 19
Section 19 -
Electronic Weatherpack Connector
09-Oct-2003 99-019-201
Engine Controls Series
- Group 19
Section 19 -
Electronic Deutsch™ DT Connector
09-Oct-2003 99-019-205
Engine Controls Series
- Group 19
Section 19 -
Electronic Deutsch™ HD10
09-Oct-2003 99-019-207
Engine Controls Connector Series
- Group 19
Section 19 -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 3 of 37

Electronic
AMP VP44 Connector
09-Oct-2003 Engine Controls 99-019-210
Series
- Group 19
Section 19 -
Electronic Packard Relay
09-Oct-2003 99-019-211
Engine Controls Connector
- Group 19
Section 19 -
Electronic
09-Oct-2003 99-019-212 Ford Connector Series
Engine Controls
- Group 19
Section 19 -
Electronic D-Sub Miniature
09-Oct-2003 99-019-213
Engine Controls Connector Series
- Group 19
Section 19 -
Electronic Framatome Connector
09-Oct-2003 99-019-218
Engine Controls Series
- Group 19
Section V - Fraction, Decimal,
03-Mar-2004 99-018-010
Specifications Multimeter Conversions
Section V - Newton-Meter to Foot-
03-Mar-2004 99-018-011
Specifications Pound Conversion Chart
Section V -
03-Mar-2004 99-018-012 Pipe Plug Torque Values
Specifications
Section V - Tap-Drill Chart - U.S.
03-Mar-2004 99-018-013
Specifications Customary and Metric
Section V - Weights and Measures -
03-Mar-2004 99-018-014
Specifications Conversion Factors
Section 19 -
Electronic Deutsch™ HD20 and
09-Jun-2004 99-019-208
Engine Controls HD30 Connector Series
- Group 19
4021560-
31-Jan-2006 Back Backcover
backcover
Section 19 -
Electronic 105-019-
06-Feb-2006 Engine Data Links
Engine Controls 428
- Group 19
4021560-
13-Feb-2006 Front Titlepage
titlepage
Section F -
13-Feb-2006 16-209-001 System Description
Familiarization
Section F - Electronic Controlled
13-Feb-2006 16-101-007
Familiarization Fuel System
Section F - Electronic Engine
13-Feb-2006 16-019-999
Familiarization Controls - Overview
Section L -
Additional Service
13-Feb-2006 Service 16-205-001
Literature
Literature
Section 19 -
Electronic Engine Brake Level
14-Feb-2006 16-019-036
Engine Controls Switch
- Group 19
Section 19 -
Electronic Engine Position Sensor
14-Feb-2006 16-019-038
Engine Controls (EPS)
- Group 19
Section 19 -
Electronic
14-Feb-2006 16-019-043 Engine Wiring Harness
Engine Controls
- Group 19

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 4 of 37

Section 19 -
Electronic
14-Feb-2006 16-019-045 Fan Control Circuit
Engine Controls
- Group 19
Section 19 -
Electronic
14-Feb-2006 16-019-050 Fuel Shutoff Valve
Engine Controls
- Group 19
Section 19 -
Electronic
14-Feb-2006 16-019-057 Injector Solenoid
Engine Controls
- Group 19
Section 19 -
Electronic
14-Feb-2006 16-019-058 Injector Solenoid Circuit
Engine Controls
- Group 19
Section 19 -
Electronic Internal Actuator Wiring
14-Feb-2006 16-019-063
Engine Controls Harness
- Group 19
Section 19 -
Electronic Engine Oil Temperature
14-Feb-2006 16-019-067
Engine Controls Sensor
- Group 19
Section 19 -
Electronic
14-Feb-2006 16-019-083 Tachometer Circuit
Engine Controls
- Group 19
Section 19 -
Electronic Unswitched Battery
14-Feb-2006 16-019-087
Engine Controls Supply Circuit
- Group 19
Section E -
Engine and
20-Feb-2006 16-100-001 Engine Identification
System
Identification
Section 19 -
Electronic Barometric Air Pressure
20-Feb-2006 16-019-004
Engine Controls Sensor
- Group 19
Section 19 -
Electronic Engine Coolant Level
20-Feb-2006 16-019-017
Engine Controls Sensor
- Group 19
Section 19 -
Electronic Engine Coolant
20-Feb-2006 16-019-019
Engine Controls Temperature Sensor
- Group 19
Section 19 -
Electronic Fuel Rail Pressure
20-Feb-2006 16-019-115
Engine Controls Sensor
- Group 19
Section 19 -
Electronic Engine Fuel
20-Feb-2006 16-019-119
Engine Controls Temperature Sensor
- Group 19
Section 19 -
Electronic
20-Feb-2006 16-019-127 Water in Fuel Sensor
Engine Controls
- Group 19

Section 19 -
20-Feb-2006 Electronic 16-019-136 Engine Brake Harness
Engine Controls

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 5 of 37

- Group 19
Section 19 -
Electronic Real-Time Clock Battery
20-Feb-2006 16-019-311
Engine Controls Backup
- Group 19
Section 19 -
Electronic Camshaft Position
20-Feb-2006 16-019-363
Engine Controls Sensor
- Group 19
Section 19 -
Electronic Crankshaft Position
20-Feb-2006 16-019-365
Engine Controls Sensor
- Group 19
Section 19 -
Electronic EGR Temperature
20-Feb-2006 16-019-378
Engine Controls Sensor
- Group 19
Section 19 -
Turbocharger
Electronic
20-Feb-2006 16-019-395 Compressor Intake Air
Engine Controls
Temperature Sensor
- Group 19
Section 19 -
Electronic
20-Feb-2006 16-019-396 Fuel Lift Pump
Engine Controls
- Group 19
Section 19 -
Electronic
20-Feb-2006 16-019-397 Fuel Lift Pump Circuit
Engine Controls
- Group 19
Section 19 -
Electronic Crankcase Pressure
20-Feb-2006 16-019-445
Engine Controls Sensor
- Group 19
22-May-2006 Front tr-frwd Foreword
Section TF -
Sensor Supply 2 Circuit
24-May-2006 Troubleshooting 16-fc187
Choice
Fault Codes
Section TF -
Coolant Level Sensor 1
25-May-2006 Troubleshooting 16-fc195
Circuit Choice
Fault Codes
Section TF -
Coolant Level Sensor 1
25-May-2006 Troubleshooting 16-fc196
Circuit Choice
Fault Codes
Section TF - Turbocharger 1 Speed -
30-May-2006 Troubleshooting 16-fc686 Data Erratic, Intermittent,
Fault Codes or Incorrect
Engine Crankshaft
Section TF -
Speed/Position - Data
30-May-2006 Troubleshooting 16-fc689
Erratic, Intermittent, or
Fault Codes
Incorrect
Section TF - Engine Camshaft
30-May-2006 Troubleshooting 16-fc778 Speed/Position Sensor
Fault Codes Choice
Section TF - Engine Brake Actuator
30-May-2006 Troubleshooting 16-fc2363 Driver Output 2 Circuit
Fault Codes Choice
Section TF - Engine Brake Actuator
30-May-2006 Troubleshooting 16-fc2367 Driver Output 2 Circuit
Fault Codes Choice

Section 19 - 16-022-
01-Jun-2006 Electronic Service Tools
001_19
Engine Controls

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 6 of 37

- Group 19
Section TS -
4021560-
07-Jun-2006 Troubleshooting Engine Will Not Shut Off
t081-tr
Symptoms
Section TS -
4021560- Fault Code Warning
07-Jun-2006 Troubleshooting
t084-tr Lamps Do Not Illuminate
Symptoms
Section L -
Service Literature
27-Jun-2006 Service 99-205-002
Ordering Location
Literature
Section 19 -
Electronic Engine Oil Pressure
26-Oct-2006 16-019-066
Engine Controls Sensor
- Group 19
Section 19 -
Electronic Electronic Control
15-Jan-2007 16-019-031
Engine Controls Module
- Group 19
Section 19 -
Intake Manifold
Electronic
15-Jan-2007 16-019-159 Pressure/Temperature
Engine Controls
Sensor
- Group 19
Section 19 -
Electronic EGR Differential
20-Feb-2007 16-019-370
Engine Controls Pressure Sensor
- Group 19
Section 19 -
Electronic Turbocharger Speed
13-Mar-2007 16-019-390
Engine Controls Sensor
- Group 19
Section V -
17-May-2007 4021644 Specifications
Specifications
Section V -
21-May-2007 4021643 Specifications
Specifications
Section i - General Cleaning
24-Jul-2007 99-204-008
Introduction Instruction
Section TT -
ECM - No
Troubleshooting
07-Dec-2007 00-ttecm Communication
Symptoms (New
Troubleshooting Tree
Format)
Exhaust Gas
Section TF -
Recirculation Valve Delta
03-Jan-2008 Troubleshooting 16-fc1866
Pressure - Data Erratic,
Fault Codes
Intermittent, or Incorrect
Aftertreatment Exhaust
Section TF - Gas Temperature 3
03-Jan-2008 Troubleshooting 16-fc1876 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Aftertreatment Exhaust
Section TF - Gas Temperature 3
03-Jan-2008 Troubleshooting 16-fc1877 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
Aftertreatment
Particulate Filter
Section TF -
Differential Pressure
03-Jan-2008 Troubleshooting 16-fc1879
Sensor Circuit - Voltage
Fault Codes
Above Normal, or
Shorted to High Source
Aftertreatment
03-Jan-2008 Section TF - 16-fc1883 Particulate Filter
Troubleshooting Differential Pressure

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 7 of 37

Fault Codes Sensor - Data Erratic,


Intermittent, or Incorrect
Section TF - EGR Valve Controller -
03-Jan-2008 Troubleshooting 16-fc1895 Bad Intelligent Device or
Fault Codes Component
Section TF -
EGR Valve Controller -
03-Jan-2008 Troubleshooting 16-fc1896
Out of Calibration
Fault Codes
Engine Coolant
Section TF - Temperature 1 Sensor
25-Jan-2008 Troubleshooting 16-fc144 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Engine Coolant
Section TF - Temperature 1 Sensor
25-Jan-2008 Troubleshooting 16-fc145 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
Sensor Supply 2 Circuit -
Section TF -
16- Voltage Below Normal,
25-Jan-2008 Troubleshooting
fc187ism or Shorted to Low
Fault Codes
Source
Sensor Supply 2 Circuit -
Section TF -
Voltage Below Normal,
25-Jan-2008 Troubleshooting 16-fc187isx
or Shorted to Low
Fault Codes
Source
Coolant Level Sensor 1
Section TF -
16-fc195- Circuit - Voltage Above
25-Jan-2008 Troubleshooting
2wire Normal, or Shorted to
Fault Codes
High Source
Coolant Level Sensor 1
Section TF -
16-fc195- Circuit - Voltage Above
25-Jan-2008 Troubleshooting
3wire Normal, or Shorted to
Fault Codes
High Source
Coolant Level Sensor 1
Section TF -
16-fc196- Circuit - Voltage Below
25-Jan-2008 Troubleshooting
2wire Normal, or Shorted to
Fault Codes
Low Source
Coolant Level Sensor 1
Section TF -
16-fc196- Circuit - Voltage Below
25-Jan-2008 Troubleshooting
3wire Normal, or Shorted to
Fault Codes
Low Source
Engine Oil Temperature
Section TF - Sensor 1 Circuit -
25-Jan-2008 Troubleshooting 16-fc213 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Engine Oil Temperature
Section TF - High - Data Valid but
25-Jan-2008 Troubleshooting 16-fc214 Above Normal
Fault Codes Operational Range -
Most Severe Level
Barometric Pressure
Section TF -
Sensor Circuit - Voltage
25-Jan-2008 Troubleshooting 16-fc221
Above Normal, or
Fault Codes
Shorted to High Source
Barometric Pressure
Section TF -
Sensor Circuit - Voltage
25-Jan-2008 Troubleshooting 16-fc222
Below Normal, or
Fault Codes
Shorted to Low Source
Section TF - Sensor Supply 2 Circuit -
25-Jan-2008 Troubleshooting 16-fc227 Voltage Above Normal,
Fault Codes or Shorted to High

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 8 of 37

Source
Engine Crankshaft
Section TF - Speed/Position - Data
25-Jan-2008 Troubleshooting 16-fc234 Valid but Above Normal
Fault Codes Operational Range -
Most Severe Level
Sensor Supply 3 Circuit -
Section TF -
Voltage Below Normal,
25-Jan-2008 Troubleshooting 16-fc238
or Shorted to Low
Fault Codes
Source
Section TF - Wheel-Based Vehicle
25-Jan-2008 Troubleshooting 16-fc241 Speed - Data Erratic,
Fault Codes Intermittent or Incorrect
Wheel-Based Vehicle
Section TF - Speed Sensor Circuit
25-Jan-2008 Troubleshooting 16-fc242 Tampering Has Been
Fault Codes Detected - Abnormal
Rate of Change
Section TF - Fan Control Circuit -
25-Jan-2008 Troubleshooting 16-fc245 Voltage Below Normal or
Fault Codes Shorted to Low Source
Ambient Air Temperature
Section TF - Sensor 1 Circuit -
25-Jan-2008 Troubleshooting 16-fc249 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Engine Fuel Shutoff
Section TF - Valve Driver Circuit -
25-Jan-2008 Troubleshooting 16-fc254 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Engine Fuel Shutoff
Section TF - Valve Driver Circuit -
25-Jan-2008 Troubleshooting 16-fc255 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Ambient Air Temperature
Section TF - Sensor 1 Circuit -
25-Jan-2008 Troubleshooting 16-fc256 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Engine Fuel
Section TF - Temperature Sensor 1
25-Jan-2008 Troubleshooting 16-fc263 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Engine Fuel
Section TF - Temperature Sensor 1
25-Jan-2008 Troubleshooting 16-fc265 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
SAE J1939 Multiplexed
Section TF - Accelerator Pedal or
25-Jan-2008 Troubleshooting 16-fc287 Lever Sensor System -
Fault Codes Received Network Data
In Error
SAE J1939 Multiplexing
Remote Accelerator
Section TF -
Pedal or Lever Position
25-Jan-2008 Troubleshooting 16-fc288
Sensor System -
Fault Codes
Received Network Data
In Error

Section TF - Barometric Pressure -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 9 of 37

Troubleshooting Data Erratic, Intermittent,


25-Jan-2008 16-fc295
Fault Codes or Incorrect
Injector Solenoid Driver
Section TF -
Cylinder 1 Circuit -
25-Jan-2008 Troubleshooting 16-fc311
Current Above Normal,
Fault Codes
or Grounded Circuit
Injector Solenoid Driver
Section TF -
Cylinder 5 Circuit -
25-Jan-2008 Troubleshooting 16-fc312
Current Above Normal,
Fault Codes
or Grounded Circuit
Injector Solenoid Driver
Section TF -
Cylinder 3 Circuit -
25-Jan-2008 Troubleshooting 16-fc313
Current Above Normal,
Fault Codes
or Grounded Circuit
Injector Solenoid Driver
Section TF -
Cylinder 6 Circuit -
25-Jan-2008 Troubleshooting 16-fc314
Current Above Normal,
Fault Codes
or Grounded Circuit
Injector Solenoid Driver
Section TF -
Cylinder 2 Circuit -
25-Jan-2008 Troubleshooting 16-fc315
Current Above Normal,
Fault Codes
or Grounded Circuit
Section TF - Real Time Clock Power
25-Jan-2008 Troubleshooting 16-fc319 Interrupt - Data Erratic,
Fault Codes Intermittent, or Incorrect
Engine Control Module
Section TF - Warning Internal
25-Jan-2008 Troubleshooting 16-fc343 Hardware Failure - Bad
Fault Codes Intelligent Device or
Component
Engine Control Module
Section TF -
Calibration Memory
25-Jan-2008 Troubleshooting 16-fc346
Software - Bad Intelligent
Fault Codes
Device or Component
Sensor Supply 1 Circuit -
Section TF -
Voltage Below Normal,
25-Jan-2008 Troubleshooting 16-fc352
or Shorted to Low
Fault Codes
Source
Sensor Supply 1 Circuit -
Section TF -
Voltage Above Normal,
28-Jan-2008 Troubleshooting 16-fc386
or Shorted to High
Fault Codes
Source
Engine Oil Rifle Pressure
Section TF - - Data Valid but Below
28-Jan-2008 Troubleshooting 16-fc415 Normal Operational
Fault Codes Range - Most Severe
Level
Water in Fuel Indicator -
Section TF - Data Valid but Above
28-Jan-2008 Troubleshooting 16-fc418 Normal Operational
Fault Codes Range - Least Severe
Level
Section TF -
SAE J1939 Datalink -
28-Jan-2008 Troubleshooting 16-fc427
Abnormal Update Rate
Fault Codes
Water-in-Fuel Indicator
Section TF -
Sensor Circuit - Voltage
28-Jan-2008 Troubleshooting 16-fc429
Below Normal, or
Fault Codes
Shorted to Low Source
Battery 1 Voltage - Data
Section TF -
Valid but Below Normal
28-Jan-2008 Troubleshooting 16-fc441
Operational Range -
Fault Codes
Moderately Severe Level

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 10 of 37

Battery 1 Voltage - Data


Section TF -
Valid but Above Normal
28-Jan-2008 Troubleshooting 16-fc442
Operational Range -
Fault Codes
Moderately Severe Level
Fuel Delivery Pressure
Section TF -
Sensor Circuit - Voltage
28-Jan-2008 Troubleshooting 16-fc546
Above Normal, or
Fault Codes
Shorted to High Source
Section 19 - Resistance
Electronic Measurement Using a
28-Jan-2008 99-019-360
Engine Controls Multimeter and Wiring
- Group 19 Diagram
Fuel Delivery Pressure
Section TF -
Sensor Circuit - Voltage
30-Jan-2008 Troubleshooting 16-fc547
Below Normal, or
Fault Codes
Shorted to Low Source
Starter Relay Driver
Section TF -
Circuit - Voltage Above
30-Jan-2008 Troubleshooting 16-fc584
Normal, or Shorted to
Fault Codes
High Source
Starter Relay Driver
Section TF -
Circuit - Voltage Below
30-Jan-2008 Troubleshooting 16-fc585
Normal, or Shorted to
Fault Codes
Low Source
Electrical Charging
Section TF - System Voltage - Data
30-Jan-2008 Troubleshooting 16-fc596 Valid but Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Electrical Charging
Section TF - System Voltage - Data
30-Jan-2008 Troubleshooting 16-fc597 Valid but Below Normal
Fault Codes Operational Range -
Moderately Severe Level
Electrical Charging
Section TF - System Voltage - Data
30-Jan-2008 Troubleshooting 16-fc598 Valid but Below Normal
Fault Codes Operational Range -
Most Severe Level
Section TF - Engine Oil Change
30-Jan-2008 Troubleshooting 16-fc649 Interval - Condition
Fault Codes Exists
Turbocharger 1 Speed -
Section TF - Data Valid but Below
30-Jan-2008 Troubleshooting 16-fc687 Normal Operational
Fault Codes Range - Moderately
Severe Level
Engine Crankshaft
Section TF -
16- Speed/Position - Data
30-Jan-2008 Troubleshooting
fc689ism Erratic, Intermittent, or
Fault Codes
Incorrect
Engine Crankshaft
Section TF -
Speed/Position - Data
30-Jan-2008 Troubleshooting 16-fc689isx
Erratic, Intermittent, or
Fault Codes
Incorrect
Turbocharger 1
Compressor Inlet
Section TF -
Temperature Sensor
30-Jan-2008 Troubleshooting 16-fc691
Circuit - Voltage Above
Fault Codes
Normal, or Shorted to
High Source

Turbocharger 1
Section TF - Compressor Inlet

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 11 of 37

Troubleshooting Temperature Sensor


Fault Codes Circuit - Voltage Below
30-Jan-2008 16-fc692
Normal, or Shorted to
Low Source
ECM Internal
Section TF - Temperature Sensor
30-Jan-2008 Troubleshooting 16-fc697 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
ECM Internal
Section TF - Temperature Sensor
30-Jan-2008 Troubleshooting 16-fc698 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
Engine Speed / Position
Camshaft and
Section TF -
Crankshaft Misalignment
30-Jan-2008 Troubleshooting 16-fc731
- Mechanical System Not
Fault Codes
Responding Properly or
Out of Adjustment
Aftertreatment Fuel
Section TF - Pressure Sensor -
31-Jan-2008 Troubleshooting 16-fc1927 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Aftertreatment Fuel
Section TF - Pressure Sensor -
31-Jan-2008 Troubleshooting 16-fc1928 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Aftertreatment Fuel
Section TF - shutoff Valve 1 Circuit -
01-Feb-2008 Troubleshooting 16-fc1923 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Aftertreatment Fuel
Section TF - Shutoff Valve 1 Circuit -
01-Feb-2008 Troubleshooting 16-fc1924 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Engine Camshaft
Section TF -
16- Speed/Position Sensor -
04-Feb-2008 Troubleshooting
fc778ism Data Erratic, Intermittent,
Fault Codes
or Incorrect
Engine Camshaft
Section TF -
Speed/Position Sensor -
04-Feb-2008 Troubleshooting 16-fc778isx
Data Erratic, Intermittent,
Fault Codes
or Incorrect
Section TF - Adaptive Cruise Control
04-Feb-2008 Troubleshooting 16-fc784 Mode - Data Erratic,
Fault Codes Intermittent, or Incorrect
Catalyst Inlet
Section TF -
Temperature Sensor
04-Feb-2008 Troubleshooting 16-fc1663
Swapped with Outlet -
Fault Codes
Condition Exists
Section TF -
Catalyst Missing -
04-Feb-2008 Troubleshooting 16-fc1664
Condition Exists
Fault Codes
Aftertreatment Exhaust
Section TF - Gas Temperature 1
04-Feb-2008 Troubleshooting 16-fc1665 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 12 of 37

Aftertreatment Exhaust
Section TF - Gas Temperature 1
04-Feb-2008 Troubleshooting 16-fc1666 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Aftertreatment Exhaust
Section TF - Gas Temperature 2
04-Feb-2008 Troubleshooting 16-fc1674 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
Aftertreatment Exhaust
Section TF - Gas Temperature 2
04-Feb-2008 Troubleshooting 16-fc1675 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Sensor Supply 5 -
Section TF -
Voltage Above Normal,
04-Feb-2008 Troubleshooting 16-fc1695
or Shorted to High
Fault Codes
Source
Sensor Supply 5 -
Section TF -
Voltage Below Normal,
04-Feb-2008 Troubleshooting 16-fc1696
or Shorted to Low
Fault Codes
Source
Crankcase Pressure
Section TF -
Circuit - Voltage Above
04-Feb-2008 Troubleshooting 16-fc1843
Normal, or Shorted to
Fault Codes
High Source
Crankcase Pressure
Section TF -
Circuit - Voltage Below
04-Feb-2008 Troubleshooting 16-fc1844
Normal, or Shorted to
Fault Codes
Low Source
ECU Power Output
Section TF - Supply Voltage 2 - Data
06-Feb-2008 Troubleshooting 16-fc1933 Valid but Above Normal
Fault Codes Operational Range -
Moderately Severe Level
ECU Power Output
Section TF - Supply Voltage 2 - Data
06-Feb-2008 Troubleshooting 16-fc1934 Valid but Below Normal
Fault Codes Operational Range -
Moderately Severe Level
Section TF - EGR Actuator Driver
06-Feb-2008 Troubleshooting 16-fc1935 Circuit - Root Cause Not
Fault Codes Known
ECU Power Output
Section TF - Supply Voltage 1 - Data
06-Feb-2008 Troubleshooting 16-fc1938 Valid but Below Normal
Fault Codes Operational Range -
Moderately Severe Level
EGR Valve Control
Circuit Calculated Over
Section TF -
Temperature - Data Valid
06-Feb-2008 Troubleshooting 16-fc1961
but Above Normal
Fault Codes
Operational Range -
Least Severe Level
VGT Actuator Driver
Over Temperature
Section TF -
(Calculated) - Data Valid
06-Feb-2008 Troubleshooting 16-fc1962
but Above Normal
Fault Codes
Operational Range -
Least Severe Level
Section TF - Crankcase Pressure -
08-Feb-2008 Troubleshooting 16-fc1942 Data Erratic, Intermittent,
Fault Codes or Incorrect

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 13 of 37

Crankcase Pressure -
Section TF - Data Valid but Above
08-Feb-2008 Troubleshooting 16-fc1974 Normal Operational
Fault Codes Range - Least Severe
Level
Engine Brake Actuator
Section TF -
Driver 1 Circuit - Voltage
08-Feb-2008 Troubleshooting 16-fc2182
Above Normal, or
Fault Codes
Shorted to High Source
Sensor Supply 4 Circuit -
Section TF -
Voltage Above Normal,
08-Feb-2008 Troubleshooting 16-fc2185
or Shorted to High
Fault Codes
Source
Sensor Supply 4 Circuit -
Section TF -
Voltage Below Normal,
08-Feb-2008 Troubleshooting 16-fc2186
or Shorted to Low
Fault Codes
Source
Auxiliary Equipment
Section TF -
Sensor Input 3 Engine
08-Feb-2008 Troubleshooting 16-fc2195
Protection Critical -
Fault Codes
Special Instructions
Section TF - VGT Actuator Driver
08-Feb-2008 Troubleshooting 16-fc2198 Circuit - Root Cause Not
Fault Codes Known
Fuel Pump Delivery
Section TF - Pressure - Data Valid but
08-Feb-2008 Troubleshooting 16-fc2216 Above Normal
Fault Codes Operational Range -
Moderately Severe Level
EGR Valve Position
Section TF -
Circuit - Voltage Below
08-Feb-2008 Troubleshooting 16-fc2272
Normal, or Shorted to
Fault Codes
Low Source
Exhaust Gas
Recirculation Valve Delta
Section TF -
Pressure Sensor Circuit -
08-Feb-2008 Troubleshooting 16-fc2273
Voltage Above Normal,
Fault Codes
or Shorted to High
Source
Exhaust Gas
Recirculation Valve Delta
Section TF -
Pressure Sensor Circuit -
08-Feb-2008 Troubleshooting 16-fc2274
Voltage Below Normal,
Fault Codes
or Shorted to Low
Source
Section TF - Electronic Fuel Injection
08-Feb-2008 Troubleshooting 16-fc2311 Control Valve Circuit -
Fault Codes Condition Exists
Section TF -
Timing Actuator Driver
08-Feb-2008 Troubleshooting 16-fc2312
Circuit - Condition Exists
Fault Codes
Section TF - Fuel Control Valve
08-Feb-2008 Troubleshooting 16-fc2313 Solenoid Driver 2 Circuit
Fault Codes - Condition Exists
Section TF - Engine Timing Actuator
08-Feb-2008 Troubleshooting 16-fc2314 Driver 2 Circuit Error -
Fault Codes Condition Exists

Turbocharger
Section TF - Compressor Outlet
08-Feb-2008 Troubleshooting 16-fc2347 Temperature
Fault Codes (Calculated) - Data Valid
but Above Normal
Operational Range -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 14 of 37

Least Severe Level


Section TF - EGR Valve Control
08-Feb-2008 Troubleshooting 16-fc2349 Circuit - Current Below
Fault Codes Normal, or Open Circuit
EGR Valve Control
Section TF -
Circuit - Voltage Below
08-Feb-2008 Troubleshooting 16-fc2351
Normal, or Shorted to
Fault Codes
Low Source
Engine Brake Actuator
Section TF - Driver Output 2 Circuit -
16-
08-Feb-2008 Troubleshooting Voltage Below Normal,
fc2363isx
Fault Codes or Shorted to Low
Source
Engine Brake Actuator
Section TF - Driver Output 3 Circuit -
08-Feb-2008 Troubleshooting 16-fc2365 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Engine Brake Actuator
Section TF - Driver Output 2 Circuit -
16-
08-Feb-2008 Troubleshooting Voltage Above Normal,
fc2367ism
Fault Codes or Shorted to High
Source
Engine Brake Actuator
Section TF - Driver Output 3 Circuit -
08-Feb-2008 Troubleshooting 16-fc2368 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Exhaust Gas Pressure
Section TF -
Sensor Circuit - Voltage
08-Feb-2008 Troubleshooting 16-fc2373
Above Normal, or
Fault Codes
Shorted to High Source
Exhaust Gas Pressure
Section TF -
Sensor Circuit - Voltage
08-Feb-2008 Troubleshooting 16-fc2374
Below Normal, or
Fault Codes
Shorted to Low Source
Exhaust Gas
Recirculation
Section TF -
Temperature Sensor
08-Feb-2008 Troubleshooting 16-fc2375
Circuit - Voltage Above
Fault Codes
Normal, or Shorted to
High Source
Exhaust Gas
Recirculation
Section TF -
Temperature Sensor
08-Feb-2008 Troubleshooting 16-fc2376
Circuit - Voltage Below
Fault Codes
Normal, or Shorted to
Low Source
Fan Control Circuit -
Section TF -
Voltage Above Normal,
08-Feb-2008 Troubleshooting 16-fc2377
or Shorted to High
Fault Codes
Source
Section TF - Fan Speed - Data
08-Feb-2008 Troubleshooting 16-fc2412 Erratic, Intermittent, or
Fault Codes Incorrect
Coolant Level - Data
Section TF -
Valid but Below Normal
08-Feb-2008 Troubleshooting 16-fc2448
Operational Range -
Fault Codes
Least Severe Level

Section TF - Remote Accelerator


13-Feb-2008 Troubleshooting 16-fc134 Pedal or Lever Position
Fault Codes Sensor 1 Circuit -
Voltage Below Normal,

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 15 of 37

or Shorted to Low
Source
Engine Oil Rifle Pressure
Section TF - 1 Sensor Circuit -
13-Feb-2008 Troubleshooting 16-fc135 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Section TF -
VGT Actuator Driver
13-Feb-2008 Troubleshooting 16-fc2635
Circuit - Condition Exists
Fault Codes
Aftertreatment
Particulate Filter
Section TF - Differential Pressure -
13-Feb-2008 Troubleshooting 16-fc2639 Data Valid but Above
Fault Codes Normal Operational
Range - Least Severe
Level
Section TF - Engine Coolant
13-Feb-2008 Troubleshooting 16-fc2646 Temperature - Condition
Fault Codes Exists
Section TF - Engine Coolant
13-Feb-2008 Troubleshooting 16-fc2659 Temperature - Condition
Fault Codes Exists
Start Enable Device 1
Section TF -
Circuit (Ether Injection) -
13-Feb-2008 Troubleshooting 16-fc2738
Voltage Above Normal or
Fault Codes
Shorted to High Source
Start Enable Device 1
Section TF -
Circuit (Ether Injection) -
13-Feb-2008 Troubleshooting 16-fc2739
Voltage Below Normal or
Fault Codes
Shorted to Low Source
Section TF - Aftertreatment Fuel
13-Feb-2008 Troubleshooting 16-fc2741 Shutoff Valve 1 Swapped
Fault Codes - Condition Exists
Aftertreatment Exhaust
Gas Temperature 2 -
Section TF -
Data Valid but Below
13-Feb-2008 Troubleshooting 16-fc2742
Normal Operational
Fault Codes
Range - Least Severe
Level
Aftertreatment Exhaust
Gas Temperature 2 -
Section TF -
Data Valid but Below
13-Feb-2008 Troubleshooting 16-fc2743
Normal Operational
Fault Codes
Range - Moderately
Severe Level
Engine Particulate Filter
Section TF - Inlet Pressure - Data
13-Feb-2008 Troubleshooting 16-fc2754 Valid but Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Engine Exhaust Gas
Section TF -
Recirculation (EGR)
13-Feb-2008 Troubleshooting 16-fc2774
System - Condition
Fault Codes
Exists
Particulate Trap Active
Section TF -
Regeneration Inhibited
13-Feb-2008 Troubleshooting 16-fc2777
Due to Inhibit Switch -
Fault Codes
Condition Exists

Section TF - Engine Coolant


13-Feb-2008 Troubleshooting 16-fc2789 Temperature - Data Valid
Fault Codes but Below Normal
Operational Range -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 16 of 37

Moderately Severe Level


Section TF -
EGR Valve Control -
13-Feb-2008 Troubleshooting 16-fc2813
Special Instructions
Fault Codes
Exhaust Gas
Recirculation
Section TF -
Temperature - Data Valid
13-Feb-2008 Troubleshooting 16-fc2962
but Above Normal
Fault Codes
Operational Range -
Moderately Severe Level
Intake Manifold 1
Section TF - Temperature - Data Valid
13-Feb-2008 Troubleshooting 16-fc2964 but Above Normal
Fault Codes Operational Range -
Least Severe Level
EGR Valve Control
Section TF - Circuit - Mechanical
28-Feb-2008 Troubleshooting 16-fc2357 System Not Responding
Fault Codes Properly or Out of
Adjustment
Accelerator Pedal or
Section TF -
Lever Position Sensor 1
07-May-2008 Troubleshooting 16-fc1242
and 2 - Data Erratic,
Fault Codes
Intermittent, or Incorrect
Section V -
08-May-2008 4021574 Specifications
Specifications
Section V -
12-May-2008 4021575 Specifications
Specifications
Section 19 -
Electronic
30-May-2008 99-019-008 Battery Ground Circuit
Engine Controls
- Group 19
Section 19 -
Electronic Cruise Control or PTO
30-May-2008 99-019-022
Engine Controls ON/OFF Switch Circuit
- Group 19
Section 19 -
Cruise Control or PTO
Electronic
30-May-2008 99-019-024 Set/Resume Select
Engine Controls
Switch Circuit
- Group 19
Section 19 -
Electronic
30-May-2008 99-019-028 Diagnostic Switch Circuit
Engine Controls
- Group 19
Section 19 -
Electronic Engine Brake ON/OFF
30-May-2008 99-019-034
Engine Controls Switch
- Group 19
Section 19 -
Electronic Engine Brake ON/OFF
30-May-2008 99-019-035
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic
30-May-2008 99-019-047 Fault Lamp Circuit
Engine Controls
- Group 19
Section 19 -
Electronic
30-May-2008 99-019-053 Idle Adjust Switch Circuit
Engine Controls
- Group 19
Section 19 -
30-May-2008 Electronic 99-019-071 OEM Wiring Harness
Engine Controls

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 17 of 37

- Group 19
Section 19 -
Programmable Features
Electronic
30-May-2008 99-019-078 and Parameters Not
Engine Controls
Correct
- Group 19
Section 19 -
Electronic Remote PTO Switch
30-May-2008 99-019-079
Engine Controls Circuit
- Group 19
Section 19 -
Electronic Brake Pedal Position
30-May-2008 99-019-089
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic Vehicle Speed Sensor,
30-May-2008 99-019-091
Engine Controls Magnetic Pick Up
- Group 19
Section 19 -
Electronic Vehicle Speed Sensor
30-May-2008 99-019-093
Engine Controls Circuit
- Group 19
Section 19 -
Electronic Data Link Circuit, SAE
30-May-2008 99-019-166
Engine Controls J1587
- Group 19
Section 19 -
Electronic Power Train Protection
30-May-2008 99-019-253
Engine Controls Switch
- Group 19
Section 19 -
Electronic Power Train Protection
30-May-2008 99-019-254
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic Air Conditioning
30-May-2008 99-019-261
Engine Controls Pressure Switch
- Group 19
Section 19 -
Electronic Air Conditioning
30-May-2008 99-019-262
Engine Controls Pressure Switch Circuit
- Group 19
Section 19 -
Electronic Accelerator Interlock
30-May-2008 99-019-265
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic Cab Switchable
30-May-2008 99-019-266
Engine Controls Governor Switch
- Group 19
Section 19 -
Electronic Cab Switchable
30-May-2008 99-019-267
Engine Controls Governor Switch Circuit
- Group 19
Section 19 -
Electronic Switched Maximum
30-May-2008 99-019-268
Engine Controls Operating Speed Switch
- Group 19
Section 19 -
Switched Maximum
Electronic
30-May-2008 99-019-269 Operating Speed Switch
Engine Controls
Circuit
- Group 19
Section 19 -
Electronic Engine Protection

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 18 of 37

Engine Controls Override Switch


30-May-2008 99-019-327
- Group 19
Section 19 -
Electronic Engine Protection
30-May-2008 99-019-328
Engine Controls Override Switch Circuit
- Group 19
Section 19 -
Electronic Remote Accelerator
30-May-2008 99-019-334
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic Engine Torque Limit
30-May-2008 99-019-336
Engine Controls Control Switch Circuit
- Group 19
Section 19 -
Electronic Fan Control Switch
30-May-2008 99-019-381
Engine Controls Circuit
- Group 19
Section 19 -
Electronic Maximum Engine Speed
30-May-2008 99-019-383
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic
30-May-2008 99-019-400 OEM Pressure Sensor
Engine Controls
- Group 19
Section 19 -
Electronic OEM Pressure Sensor
30-May-2008 99-019-401
Engine Controls Circuit
- Group 19
Section 19 -
Electronic OEM Temperature
30-May-2008 99-019-402
Engine Controls Sensor
- Group 19
Section 19 -
Electronic OEM Temperature
30-May-2008 99-019-403
Engine Controls Sensor Circuit
- Group 19
Section TF - SAE J1939 Multiplexing
10-Jun-2008 Troubleshooting 16-fc285 PGN Timeout Error -
Fault Codes Abnormal Update Rate
Section TF - SAE J1939 Multiplexing
10-Jun-2008 Troubleshooting 16-fc286 Configuration Error - Out
Fault Codes of Calibration
Section 19 -
Electronic Clutch Pedal Position
11-Jun-2008 99-019-010
Engine Controls Switch Circuit
- Group 19
Section 19 -
Electronic Data Link Circuit, SAE
11-Jun-2008 99-019-165
Engine Controls J1939
- Group 19
Accelerator Pedal or
Section TF - Lever Position Sensor 2
18-Jun-2008 Troubleshooting 16-fc1241 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
Engine Oil Rifle Pressure
Section TF - - Data Valid but Below
02-Jul-2008 Troubleshooting 16-fc143 Normal Operational
Fault Codes Range - Moderately
Severe Level
Electronic Control

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 19 of 37

Section TF - Module Critical Internal


03-Sep-2008 Troubleshooting 16-fc111 Failure - Bad Intelligent
Fault Codes Device or Component
Section 19 -
Electronic Exhaust Gas Pressure
23-Sep-2008 16-019-376
Engine Controls Sensor
- Group 19
Engine Brake Actuator
Section TF - Driver Output 2 Circuit -
16-
17-Oct-2008 Troubleshooting Voltage Above Normal,
fc2367isx
Fault Codes or Shorted to High
Source
Turbocharger 1
Compressor Inlet
Section TF -
Pressure - Data Valid But
06-Nov-2008 Troubleshooting 16-fc629
Below Normal Operating
Fault Codes
Range - Moderately
Severe Level
Injector Metering Rail 2
Section TF - Pressure - Data Valid but
13-Nov-2008 Troubleshooting 16-fc2551 Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Injector Metering Rail 1
Section TF - Pressure - Data Valid but
13-Nov-2008 Troubleshooting 16-fc2552 Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Engine Fuel shutoff
Section TF - Valve Driver -
01-Dec-2008 Troubleshooting 16-fc257 Mechanical System Not
Fault Codes Responding Properly or
Out of Adjustment
Aftertreatment Fuel
Section TF -
16- Shutoff Valve 1 - Data
29-Jan-2009 Troubleshooting
fc1925ism Erratic, Intermittent, or
Fault Codes
Incorrect
Aftertreatment Fuel
Section TF -
16- Shutoff Valve 1 - Data
29-Jan-2009 Troubleshooting
fc1925isx Erratic, Intermittent, or
Fault Codes
Incorrect
Aftertreatment Fuel Drain
Section TF - Valve - Mechanical
16-
29-Jan-2009 Troubleshooting System Not Responding
fc2878ism
Fault Codes Properly or Out of
Adjustment
Aftertreatment Fuel Drain
Section TF - Valve - Mechanical
16-
29-Jan-2009 Troubleshooting System Not Responding
fc2878isx
Fault Codes Properly or Out of
Adjustment
Engine Oil Temperature
Section TF - Sensor 1 Circuit -
30-Jan-2009 Troubleshooting 16-fc212 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Accelerator Pedal or
Section TF - Lever Position Sensor 2
30-Jan-2009 Troubleshooting 16-fc1239 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Section TF -
Aftertreatment Fuel
30-Jan-2009 Troubleshooting 16-fc1925
Shutoff Valve 1 Choice
Fault Codes

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 20 of 37

Section TF -
Aftertreatment Fuel
30-Jan-2009 Troubleshooting 16-fc1963
Shutoff Valve 1 Choice
Fault Codes
Section TF -
Aftertreatment Fuel Drain
30-Jan-2009 Troubleshooting 16-fc2878
Valve Choice
Fault Codes
Section TF -
Aftertreatment Fuel Drain
30-Jan-2009 Troubleshooting 16-fc2879
Valve Choice
Fault Codes
Engine Magnetic
Section TF - Speed/Position Lost Both
03-Feb-2009 Troubleshooting 16-fc115 of Two Signals - Data
Fault Codes Erratic, Intermittent, or
Incorrect
Remote Accelerator
Pedal or Lever Position
Section TF -
Sensor 1 Circuit -
03-Feb-2009 Troubleshooting 16-fc133
Voltage Above Normal,
Fault Codes
or Shorted to High
Source
Section TF - Aftertreatment Fuel Drain
16-
03-Feb-2009 Troubleshooting Valve - Data Erratic,
fc2879ism
Fault Codes Intermittent, or Incorrect
Section TF - Aftertreatment Fuel Drain
16-
03-Feb-2009 Troubleshooting Valve - Data Erratic,
fc2879isx
Fault Codes Intermittent, or Incorrect
Section TF - Aftertreatment Fuel
11-Feb-2009 Troubleshooting 16-fc1932 Injector 1 - Data Erratic,
Fault Codes Intermittent, or Incorrect
Aftertreatment Fuel
Section TF - Shutoff Valve 1 -
16-
19-Feb-2009 Troubleshooting Mechanical System Not
fc1963ism
Fault Codes Responding Properly or
Out of Adjustment
Aftertreatment Fuel
Section TF - Shutoff Valve 1 -
16-
19-Feb-2009 Troubleshooting Mechanical System Not
fc1963isx
Fault Codes Responding Properly or
Out of Adjustment
Section TS -
4021560- Engine Brake Does Not
26-Feb-2009 Troubleshooting
t036-tr Operate
Symptoms
Engine Fan Does Not
Section TS -
4021560- Operate, Operates
03-Mar-2009 Troubleshooting
t046-tr Erratically, or Operates
Symptoms
Continuously
Engine Fuel shutoff
Section TF - Valve Driver -
16-
04-Mar-2009 Troubleshooting Mechanical System Not
fc257ism
Fault Codes Responding Properly or
Out of Adjustment
Exhaust Gas
Recirculation
Section TF -
Temperature - Data Valid
06-Mar-2009 Troubleshooting 16-fc2961
but Above Normal
Fault Codes
Operational Range -
Least Severe Level
Section TF - VGT Actuator Controller -
17-Mar-2009 Troubleshooting 16-fc2634 Bad Intelligent Device or
Fault Codes Component
Section V - Barometric Pressure at
18-Mar-2009 99-018-028
Specifications Altitude
Section 19 -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 21 of 37

Electronic
Bosch® Actuator and
19-Mar-2009 Engine Controls 99-019-214
Sensor Connector Series
- Group 19
Section 19 -
Electronic Bosch® ECM Injector
19-Mar-2009 99-019-215
Engine Controls Driver Connector Series
- Group 19
Turbocharger 1 Speed -
Section TF - Data Valid but Above
26-Mar-2009 Troubleshooting 16-fc2288 Normal Operational
Fault Codes Range - Least Severe
Level
Section TF - Power Supply Lost With
01-Apr-2009 Troubleshooting 16-fc1117 Ignition On - Data Erratic,
Fault Codes Intermittent, or Incorrect
Section TF - Roll Over Protection
06-Apr-2009 Troubleshooting 16-fc3374 Brake Control Active -
Fault Codes Condition Exists
Section TF - Anti-Lock Braking (ABS)
06-Apr-2009 Troubleshooting 16-fc3488 Controller - Abnormal
Fault Codes Update Rate
Section TF - EGR Valve Control
07-Apr-2009 Troubleshooting 16-fc1893 Circuit - Abnormal
Fault Codes Update Rate
Section 19 -
Bosch® ECM Actuator
Electronic
23-Apr-2009 99-019-216 and Sensor Connector
Engine Controls
Series
- Group 19
Section 19 -
Electronic Bosch® ECM OEM
23-Apr-2009 99-019-217
Engine Controls Connector Series
- Group 19
Aftertreatment Fuel Drain
Section TF -
Valve Circuit - Voltage
07-May-2009 Troubleshooting 16-fc2732
Above Normal or Shorted
Fault Codes
to High Source
Aftertreatment Fuel Drain
Section TF -
Valve Circuit - Voltage
07-May-2009 Troubleshooting 16-fc2733
Below Normal or Shorted
Fault Codes
to Low Source
Water-in-Fuel Indicator
Section TF -
Sensor Circuit - Voltage
12-Jun-2009 Troubleshooting 16-fc428
Above Normal, or
Fault Codes
Shorted to High Source
Section TS - Troubleshooting
99-t00-001-
25-Jun-2009 Troubleshooting Procedures and
tr
Symptoms Techniques
Ambient Air Density -
Section TF - Data Valid but Below
30-Jun-2009 Troubleshooting 16-fc1943 Normal Operational
Fault Codes Range - Least Severe
Level
Section TF - Injector Power Supply -
09-Jul-2009 Troubleshooting 16-fc351 Bad Intelligent Device or
Fault Codes Component
Section L -
Cummins Customized
22-Jul-2009 Service 99-205-004
Parts Catalog
Literature
Aftertreatment
Section TF - Particulate Filter
10-Aug-2009 Troubleshooting 16-fc1981 Differential Pressure -
Fault Codes Data Valid but Above
Normal Operational

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 22 of 37

Range - Least Severe


Level
Intake Manifold 1
Section TF - Pressure - Data Valid but
28-Aug-2009 Troubleshooting 16-fc125 Below Normal
Fault Codes Operational Range -
Moderately Severe Level
Section i - 99-204-
10-Sep-2009 About the Manual
Introduction 002-tr
Engine Fuel shutoff
Section TF - Valve Driver -
16-Sep-2009 Troubleshooting 16-fc257isx Mechanical System Not
Fault Codes Responding Properly or
Out of Adjustment
Fuel Filter Differential
Section TF - Pressure - Data Valid but
16-Sep-2009 Troubleshooting 16-fc2372 Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Section 19 -
Electronic Key Switch Battery
16-Sep-2009 99-019-064
Engine Controls Supply Circuit
- Group 19
Section TF - Turbocharger 1 Speed -
21-Sep-2009 Troubleshooting 16-fc2345 Abnormal Rate of
Fault Codes Change
Aftertreatment Fuel
Section TF - Pressure Sensor - Data
24-Sep-2009 Troubleshooting 16-fc2881 Valid but Below Normal
Fault Codes Operational Range -
Least Severe Level
Accelerator Pedal or
Section TF - Lever Position Sensor 1
30-Sep-2009 Troubleshooting 16-fc131 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Turbocharger Turbine
Inlet Temperature
Section TF -
(Calculated) - Data Valid
30-Sep-2009 Troubleshooting 16-fc2346
but Above Normal
Fault Codes
Operational Range -
Least Severe Level
Turbocharger 1
Compressor Inlet
Section TF -
Pressure - Data Valid But
30-Sep-2009 Troubleshooting 16-fc3348
Below Normal Operating
Fault Codes
Range - Most Severe
Level
Section i - 99-204- General Repair
08-Oct-2009
Introduction 007-tr Instructions
Section 19 -
Electronic 105-019-
20-Oct-2009 ECM ROM Boot
Engine Controls 427
- Group 19
Section TF - VGT Actuator Driver
29-Oct-2009 Troubleshooting 16-fc2636 Circuit - Abnormal
Fault Codes Update Rate
Injector Solenoid Driver
Section TF -
Cylinder 4 Circuit -
30-Oct-2009 Troubleshooting 16-fc321
Current Above Normal,
Fault Codes
or Grounded Circuit

30-Oct-2009 Section TF - 16-fc322 Injector Solenoid Driver


Troubleshooting Cylinder 1 Circuit -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 23 of 37

Fault Codes Current Below Normal, or


Open Circuit
Injector Solenoid Driver
Section TF -
Cylinder 5 Circuit -
30-Oct-2009 Troubleshooting 16-fc323
Current Below Normal, or
Fault Codes
Open Circuit
Injector Solenoid Driver
Section TF -
Cylinder 3 Circuit -
30-Oct-2009 Troubleshooting 16-fc324
Current Below Normal, or
Fault Codes
Open Circuit
Injector Solenoid Driver
Section TF -
Cylinder 2 Circuit -
30-Oct-2009 Troubleshooting 16-fc331
Current Below Normal, or
Fault Codes
Open Circuit
Injector Solenoid Driver
Section TF -
Cylinder 4 Circuit -
30-Oct-2009 Troubleshooting 16-fc332
Current Below Normal, or
Fault Codes
Open Circuit
Idle Shutdown Vehicle
Section TF - Accessories Relay Driver
30-Oct-2009 Troubleshooting 16-fc338 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Idle Shutdown Vehicle
Section TF - Accessories Relay Driver
30-Oct-2009 Troubleshooting 16-fc339 Circuit - Voltage Below
Fault Codes Normal, or Shorted to
Low Source
Engine Oil Rifle Pressure
Section TF - 1 Sensor Circuit -
09-Nov-2009 Troubleshooting 16-fc141 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Section TF - Engine Oil Rifle Pressure
09-Nov-2009 Troubleshooting 16-fc435 - Data Erratic,
Fault Codes Intermittent, or Incorrect
Section TF -
VGT Actuator Controller -
16-Nov-2009 Troubleshooting 16-fc2449
Out of Calibration
Fault Codes
VGT Actuator Driver
Section TF - Circuit (Motor) -
16-Nov-2009 Troubleshooting 16-fc3616 Mechanical System Not
Fault Codes Responding or Out of
Adjustment
VGT Actuator Driver
Section TF - Circuit (Motor) -
23-Nov-2009 Troubleshooting 16-fc2387 Mechanical System Not
Fault Codes Responding Properly, or
Out of Adjustment
Section 19 -
Electronic
02-Dec-2009 99-019-359 Multimeter Usage
Engine Controls
- Group 19
Section 19 -
Electronic Inactive or Intermittent
02-Dec-2009 99-019-362
Engine Controls Fault Code
- Group 19
Crankcase Pressure -
Section TF - Data Valid but Above
03-Dec-2009 Troubleshooting 16-fc555 Normal Operational
Fault Codes Range - Moderately
Severe Level

Section TF - Aftertreatment Fuel

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 24 of 37

Troubleshooting Pressure Sensor - Data


03-Dec-2009 Fault Codes 16-fc1926 Erratic, Intermittent, or
Incorrect
Section TS -
4021560- Low Idle Adjust Switch
06-Jan-2010 Troubleshooting
t099-tr Does Not Work
Symptoms
Section TF - Aftertreatment
12-Jan-2010 Troubleshooting 16-fc1993 Particulate Filter Missing
Fault Codes - Condition Exists
Exhaust Gas
Recirculation Valve Delta
Section TF -
Pressure - Data Valid but
15-Jan-2010 Troubleshooting 16-fc2359
Above Normal
Fault Codes
Operational Range -
Moderately Severe Level
Section 19 -
Electronic Aftertreatment Fuel
21-Jan-2010 16-019-444
Engine Controls Pressure Sensor
- Group 19
Accelerator Pedal or
Section TF - Lever Position Sensor 1
22-Jan-2010 Troubleshooting 16-fc132 Circuit - Voltage Below
Fault Codes Normal or Shorted to
Low Source
Crankcase Breather
Section TF -
Filter Heater Circuit -
22-Jan-2010 Troubleshooting 16-fc3733
Voltage Above Normal or
Fault Codes
Shorted to High Source
Crankcase Breather
Section TF -
Filter Heater Circuit -
22-Jan-2010 Troubleshooting 16-fc3734
Voltage Below Normal or
Fault Codes
Shorted to Low Source
Section i - 99-204- General Safety
25-Jan-2010
Introduction 006-tr Instructions
Engine Brake Actuator
Section TF -
Driver 1 Circuit - Voltage
25-Jan-2010 Troubleshooting 16-fc2183
Below Normal, or
Fault Codes
Shorted to Low Source
Engine Brake Actuator
Section TF - Driver Output 2 Circuit -
16-
25-Jan-2010 Troubleshooting Voltage Below Normal,
fc2363ism
Fault Codes or Shorted to Low
Source
Section V -
25-Jan-2010 99-018-005 Drive Belt Tension
Specifications
Section V - Capscrew Markings and
25-Jan-2010 99-018-009
Specifications Torque Values
Intake Manifold 1
Section TF - Pressure Sensor Circuit -
26-Jan-2010 Troubleshooting 16-fc122 Voltage Above Normal,
Fault Codes or Shorted to High
Source
Intake Manifold 1
Section TF - Pressure Sensor Circuit -
26-Jan-2010 Troubleshooting 16-fc123 Voltage Below Normal,
Fault Codes or Shorted to Low
Source
Intake Manifold 1
Section TF - Temperature Sensor
26-Jan-2010 Troubleshooting 16-fc153 Circuit - Voltage Above
Fault Codes Normal, or Shorted to
High Source
Intake Manifold 1

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 25 of 37

Temperature Sensor
Section TF -
Circuit - Voltage Below
26-Jan-2010 Troubleshooting 16-fc154
Normal, or Shorted to
Fault Codes
Low Source
Intake Manifold 1
Section TF - Temperature - Data Valid
26-Jan-2010 Troubleshooting 16-fc155 but Above Normal
Fault Codes Operational Range -
Most Severe Level
Section V -
26-Jan-2010 4021595 Specifications
Specifications
Aftertreatment Exhaust
Gas Temperature 1 -
Section TF -
Data Valid but Above
27-Jan-2010 Troubleshooting 16-fc1966
Normal Operational
Fault Codes
Range - Most Severe
Level
Aftertreatment Exhaust
Gas Temperature 2 -
Section TF -
Data Valid but Above
27-Jan-2010 Troubleshooting 16-fc1968
Normal Operational
Fault Codes
Range - Moderately
Severe Level
Aftertreatment Exhaust
Gas Temperature 2 -
Section TF -
Data Valid but Above
27-Jan-2010 Troubleshooting 16-fc1969
Normal Operational
Fault Codes
Range - Most Severe
Level
Aftertreatment Exhaust
Gas Temperature 3 -
Section TF -
Data Valid but Above
27-Jan-2010 Troubleshooting 16-fc1972
Normal Operational
Fault Codes
Range - Moderately
Severe Level
Aftertreatment Exhaust
Gas Temperature 3 -
Section TF -
Data Valid but Above
27-Jan-2010 Troubleshooting 16-fc1973
Normal Operational
Fault Codes
Range - Most Severe
Level
Section TF - Intake Manifold 1
28-Jan-2010 Troubleshooting 16-fc2973 Pressure - Data Erratic,
Fault Codes Intermittent, or Incorrect
Section TS -
4021560- PTO or Cruise Control
02-Feb-2010 Troubleshooting
t112-tr Does Not Operate
Symptoms
Section TF -
Catalyst Face Plugged -
16-Feb-2010 Troubleshooting 16-fc2637
Root Cause Not Known
Fault Codes
Section F - Service Tools and
18-Feb-2010 00-022-999
Familiarization Hardware - Overview
Engine Crankshaft
Section TF -
Speed/Position - Data
24-Feb-2010 Troubleshooting 16-fc2321
Erratic, Intermittent, or
Fault Codes
Incorrect
Engine Camshaft
Section TF -
Speed/Position Sensor -
24-Feb-2010 Troubleshooting 16-fc2322
Data Erratic, Intermittent,
Fault Codes
or Incorrect
Section TF - Exhaust Gas Pressure -
26-Feb-2010 Troubleshooting 16-fc2554 Data Erratic, Intermittent,
Fault Codes or Incorrect

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 26 of 37

Section 19 - Aftertreatment Diesel


Electronic Particulate Filter
01-Mar-2010 16-019-443
Engine Controls Differential Pressure
- Group 19 Sensor
Section 19 -
Electronic Aftertreatment Exhaust
01-Mar-2010 16-019-449
Engine Controls Gas Temperature Sensor
- Group 19
Aftertreatment Fuel
Section TF -
Injector 1 Circuit -
04-Mar-2010 Troubleshooting 16-fc1977
Current Below Normal, or
Fault Codes
Open Circuit
Turbocharger Turbine
Inlet Temperature
Section TF -
(Calculated) - Data Valid
09-Mar-2010 Troubleshooting 16-fc2451
but Above Normal
Fault Codes
Operational Range -
Moderately Severe Level
Fuel Pump Delivery
Section TF - Pressure - Data Valid but
15-Mar-2010 Troubleshooting 16-fc2215 Below Normal
Fault Codes Operational Range -
Moderately Severe Level
Injector Solenoid Driver
Section TF -
Cylinder 6 Circuit -
16-Mar-2010 Troubleshooting 16-fc325
Current Below Normal, or
Fault Codes
Open Circuit
Crankcase Pressure -
Section TF - Data Valid but Above
17-Mar-2010 Troubleshooting 16-fc556 Normal Operational
Fault Codes Range - Most Severe
Level
Aftertreatment
Particulate Filter
Section TF -
Differential Pressure
17-Mar-2010 Troubleshooting 16-fc1881
Sensor Circuit - Voltage
Fault Codes
Below Normal, or
Shorted to Low Source
Section i - Acronyms and
24-Mar-2010 99-204-009
Introduction Abbreviations
Section 19 -
Electronic
26-Mar-2010 16-019-110 Fueling Actuator
Engine Controls
- Group 19
Section 19 -
Electronic
26-Mar-2010 16-019-111 Timing Actuator
Engine Controls
- Group 19
Section TT -
Engine Performance
Troubleshooting 16-t02-
07-Apr-2010 Troubleshooting Tree -
Symptoms (New 1001b
ISM with CM876
Format)
Aftertreatment Exhaust
Section TF -
Gas Temperature 1 -
15-Apr-2010 Troubleshooting 16-fc1667
Data Erratic, Intermittent,
Fault Codes
or Incorrect
Section E -
Engine and
20-Apr-2010 16-100-002 Engine Diagrams
System
Identification
Section TF -
Coolant Level - Data
21-Apr-2010 Troubleshooting 16-fc197
Valid but Below Normal
Fault Codes
Operational Range -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 27 of 37

Moderately Severe Level


Aftertreatment Exhaust
Section TF -
Gas Temperature 2 -
21-Apr-2010 Troubleshooting 16-fc1676
Data Erratic, Intermittent,
Fault Codes
or Incorrect
Aftertreatment Exhaust
Section TF -
Gas Temperature 3 -
21-Apr-2010 Troubleshooting 16-fc1878
Data Erratic, Intermittent,
Fault Codes
or Incorrect
Engine Coolant
Section TF - Temperature - Data Valid
26-Apr-2010 Troubleshooting 16-fc146 but Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Engine Coolant
Section TF - Temperature - Data Valid
26-Apr-2010 Troubleshooting 16-fc151 but Above Normal
Fault Codes Operational Range -
Most Severe Level
Exhaust Gas
Recirculation Valve Delta
Section TF -
Pressure - Data Valid but
26-Apr-2010 Troubleshooting 16-fc1899
Above Normal
Fault Codes
Operational Range-
Moderately Severe Level
Engine Coolant
Section TF - Temperature - Data Valid
26-Apr-2010 Troubleshooting 16-fc2963 but Above Normal
Fault Codes Operational Range -
Least Severe Level
Exhaust Gas Pressure -
Section TF - Data Valid but Above
27-Apr-2010 Troubleshooting 16-fc2764 Normal Operational
Fault Codes Range - Moderately
Severe Level
Section TF -
Catalyst Efficiency - Out
19-May-2010 Troubleshooting 16-fc1691
of Calibration
Fault Codes
Section TF -
Catalyst Efficiency - Out
19-May-2010 Troubleshooting 16-fc2638
of Calibration
Fault Codes
Aftertreatment Fuel
Section TF - Injector 1 - Data Valid but
19-May-2010 Troubleshooting 16-fc2728 Above Normal
Fault Codes Operational Range -
Moderately Severe Level
Section i - 99-204-
25-May-2010 How to Use the Manual
Introduction 003-tr
Aftertreatment
Particulate Filter
Section TF - Differential Pressure -
11-Jun-2010 Troubleshooting 16-fc1921 Data Valid but Above
Fault Codes Normal Operational
Range - Moderately
Severe Level
Aftertreatment
Particulate Filter
Section TF - Differential Pressure -
11-Jun-2010 Troubleshooting 16-fc1922 Data Valid but Above
Fault Codes Normal Operational
Range - Most Severe
Level

Section 19 -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 28 of 37

Electronic
105-019-
16-Jun-2010 Engine Controls ECM Calibration
032
- Group 19
Section TS - Communication Error -
4021560-
23-Jun-2010 Troubleshooting Electronic Service Tool
t016-tr
Symptoms or Control Device
Section 19 -
Bosch Aftertreatment
Electronic
17-Aug-2010 99-019-474 DEF Controller Added procedure to outline.
Engine Controls
Connector
- Group 19
Exhaust Gas
Section TF - Completed update instructing to
16-t05- Recirculation Valve Delta
13-Sep-2010 Troubleshooting inspect the passages before
1866 Pressure - Data Erratic,
Fault Codes checking the circuit.
Intermittent, or Incorrect
Section TT -
Engine Performance
Troubleshooting 16-t02- Base engine checks were added for
21-Sep-2010 Troubleshooting Tree -
Symptoms (New 1001a static timing.
ISX with CM871
Format)
Aftertreatment Exhaust
Section TF - Updated troubleshooting steps by
16-t05- Gas Temperature 1 -
15-Sep-2010 Troubleshooting removal of the pin-to-pin short circuit
1667 Data Erratic, Intermittent,
Fault Codes check on the return circuit.
or Incorrect
Aftertreatment Exhaust
Section TF - Updated troubleshooting steps by
16-t05- Gas Temperature 3 -
15-Sep-2010 Troubleshooting removal of the pin-to-pin short circuit
1878 Data Erratic, Intermittent,
Fault Codes check on the return circuit.
or Incorrect
Aftertreatment Exhaust
Section TF - Updated troubleshooting steps by
16-t05- Gas Temperature 2 -
27-Sep-2010 Troubleshooting removal of the pin-to-pin short circuit
1676 Data Erratic, Intermittent,
Fault Codes check on the return circuit.
or Incorrect
Three Wire Sensor -
Section TF - Coolant Level Sensor 1
16-t05-195- Added jumper statement to Guided
27-Sep-2010 Troubleshooting Circuit - Voltage Above
3wire Step 2B.
Fault Codes Normal or Shorted to
High Source
Section 19 -
Electronic Turbocharger Speed Revisions to Remove, Inspect for
21-Oct-2010 16-019-390
Engine Controls Sensor Reuse, and Install sections.
- Group 19
Engine Fuel Shutoff
Section TF - Valve Driver -
16-t05-
13-Oct-2010 Troubleshooting Mechanical System Not Revisions to Step 3A.
257isx
Fault Codes Responding Properly or
Out of Adjustment
Section TF -
16-t05- EGR Valve Controller - Added statement to Step 2A Repair
03-Dec-2010 Troubleshooting
1896 Out of Calibration for clarification on repair procedure.
Fault Codes
Fuel Pressure Low -
Section TF - Data Valid But Below
18-Jan-2011 Troubleshooting 16-fc482 Normal Operational Added to the outline.
Fault Codes Range - Moderately
Severe Level.
Fuel Pressure Low -
Section TF - Data Valid But Below
18-Jan-2011 Troubleshooting 16-t05-482 Normal Operational Added to the outline.
Fault Codes Range - Moderately
Severe Level.
Fuel Pump Delivery
Section TF - Pressure - Data Valid But
18-Jan-2011 Troubleshooting 16-fc2215 Below Normal Operating Revision to Step 4A.
Fault Codes Range - Moderately
Severe Level

Fuel Pump Delivery

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 29 of 37

Pressure - Data Valid But


Section TF -
16-t05- Below Normal Operating
18-Jan-2011 Troubleshooting Revision to Step 4A.
2215 Range - Moderately
Fault Codes
Severe Level
Updated General Information, Initial
Section F - Service Tools and
21-Jan-2011 00-022-999 Check, Setup, and Resistance Check
Familiarization Hardware - Overview
sections.
Section TF - VGT Actuator Controller -
16-t05-
16-Feb-2011 Troubleshooting Bad Intelligent Device or Step 1A Action revised.
2634
Fault Codes Component
Section TF -
16-t05- VGT Actuator Controller -
16-Feb-2011 Troubleshooting Step 1B Action revised.
2449 Out of Calibration
Fault Codes
Intake Manifold 1
Section TF - Temperature - Data Valid
16-Feb-2011 Troubleshooting 16-fc3385 But Below Normal Added Fault Code 3385 to bulletin.
Fault Codes Operating Range -
Moderately Severe Level
Intake Manifold 1
Section TF - Temperature - Data Valid
148-t05-
16-Feb-2011 Troubleshooting But Below Normal Added Fault Code 3385 to bulletin.
3385
Fault Codes Operating Range -
Moderately Severe Level
Aftertreatment Exhaust
Gas Temperature 1 -
Section TF -
16-t05- Data Valid but Above Revised method for troubleshooting
16-Feb-2011 Troubleshooting
1966 Normal Operational turbocharger exhaust outlet.
Fault Codes
Range - Most Severe
Level
Aftertreatment Exhaust
Gas Temperature 2 -
Section TF -
16-t05- Data Valid but Above Revised method for troubleshooting
16-Feb-2011 Troubleshooting
1968 Normal Operational turbocharger exhaust outlet.
Fault Codes
Range - Moderately
Severe Level
Aftertreatment Exhaust
Gas Temperature 2 -
Section TF -
16-t05- Data Valid but Above Revised method for troubleshooting
16-Feb-2011 Troubleshooting
1969 Normal Operational turbocharger exhaust outlet.
Fault Codes
Range - Most Severe
Level
Exhaust Gas
Section TF - Temperature 3 - Data
16-t05- Revised method for troubleshooting
16-Feb-2011 Troubleshooting Valid but Above Normal
1972 turbocharger exhaust outlet.
Fault Codes Operational Range -
Moderately Severe Level
Exhaust Gas
Section TF - Temperature 3 - Data
16-t05- Revised method for troubleshooting
16-Feb-2011 Troubleshooting Valid But Above Normal
1973 turbocharger exhaust outlet.
Fault Codes Operational Range -
Most Severe Level
Section TF - Added Guided Step 1 to check the
16-t05- Catalyst Efficiency - Out
21-Feb-2011 Troubleshooting fault codes before continuing with
1691 of Calibration
Fault Codes troubleshooting.
Exhaust Gas
Recirculation Valve Delta
Section TF -
Pressure - Data Valid But Removed a note at the end of the
09-Mar-2011 Troubleshooting 16-fc2359
Above Normal Operating Shop Talk section.
Fault Codes
Range - Moderately
Severe Level
Section TF - Crankcase Pressure -
16-t05-
17-Mar-2011 Troubleshooting Data Erratic, Intermittent, Added Step 1C.
1942
Fault Codes or Incorrect

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 30 of 37

VGT Actuator Driver Updated Guided Step 2C to include


Section TF - Circuit (Motor) - the proper step name and removed
16-t05-
18-Mar-2011 Troubleshooting Mechanical System Not unnecessary text. Corrected
2387
Fault Codes Responding Properly or procedure reference and a note in
Out of Adjustment the No Repair answer.
Section TF - Intake Manifold 1 Add Guided Sted 5C - Inspect
16-t05-
21-Mar-2011 Troubleshooting Pressure - Data Erratic, turbocharger compressor and turbine
2973
Fault Codes Intermittent, or Incorrect
blades.
Section TF - Revised Guided Step 2C. Changed
16-t05- VGT Actuator Controller -
21-Mar-2011 Troubleshooting to Inspect the turbocharger sector
2449 Out of Calibration
Fault Codes gear movement.
Aftertreatment Exhaust
Section TF -
16-t05- Gas Temperature 1 -
25-Mar-2011 Troubleshooting Added Step 1B.
1667 Data Erratic, Intermittent,
Fault Codes
or Incorrect
Aftertreatment Exhaust
Section TF -
16-t05- Gas Temperature 2 -
25-Mar-2011 Troubleshooting Added Step 1B.
1676 Data Erratic, Intermittent,
Fault Codes
or Incorrect
Aftertreatment Exhaust
Section TF -
16-t05- Gas Temperature 3 -
25-Mar-2011 Troubleshooting Added Step 1B.
1878 Data Erratic, Intermittent,
Fault Codes
or Incorrect
Section TF - Intake Manifold 1 Added Step 3E (Check for a plugged
16-t05-
01-Apr-2011 Troubleshooting Pressure - Data Erratic, engine intake manifold
2973
Fault Codes Intermittent, or Incorrect pressure/temperature sensor.)
Aftertreatment Fuel
Section TF - shutoff Valve 1 Circuit -
16-t05-
11-Jul-2011 Troubleshooting Voltage Above Normal, Updated graphic is Step 2D.
1923
Fault Codes or Shorted to High
Source
Turbocharger 1 Speed -
Section TF - Data Valid But Below
11-Jul-2011 Troubleshooting 16-t05-687 Normal Operating Range Revised repair sections in Step 4D.
Fault Codes - Moderately Severe
Level
Exhaust Gas
Recirculation Valve Delta
Section TF -
16-t05- Pressure - Data Valid But
11-Jul-2011 Troubleshooting Added Step 2D.
1899 Below Normal Operating
Fault Codes
Range - Moderately
Severe Level
Section TF - Guided Steps 3A and 3C: Changed
16-t05- Catalyst Efficiency - Out
12-Jul-2011 Troubleshooting NO to Refer to t116 or t147 in TS
1691isx of Calibration
Fault Codes Section of Bulletin 3666239.
Section TF - Guided Step 5A: Changed No to
16-t05- Catalyst Efficiency - Out
12-Jul-2011 Troubleshooting Refer to t116 or t147 in TS Section of
1691ism of Calibration
Fault Codes Bulletin 3666239.
Crankcase Pressure -
Section TF - Data Valid but Above
15-Aug-2011 Troubleshooting 16-t05-556 Normal Operational Updated Steps 2C and 3A.
Fault Codes Range - Most Severe
Level
Aftertreatment Diesel
Particulate Filter
Section TF - Differential Pressure - Added note in Shop Talk that
19-Aug-2011 Troubleshooting 16-fc1921 Data Valid But Above stationary regeneration is not not
Fault Codes Normal Operating Range covered by warranty.
- Moderately Severe
Level

Aftertreatment Diesel
19-Aug-2011 16-fc1922
Section TF - Particulate Filter Added note in Shop Talk that
Troubleshooting Differential Pressure - stationary regeneration is not not

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 31 of 37

Fault Codes Data Valid But Above covered by warranty.


Normal Operating Range
- Most Severe Level
Aftertreatment Diesel
Particulate Filter
Section TF - Added note in Shop Talk that
Differential Pressure -
19-Aug-2011 Troubleshooting 16-fc2639 stationary regeneration is not not
Data Valid But Above
Fault Codes covered by warranty.
Normal Operating Range
- Least Severe Level
Aftertreatment Exhaust
Section TF -
16-t05- Gas Temperature 2 - Updated Guided Step 3C to replace
24-Aug-2011 Troubleshooting
1676 Data Erratic, Intermittent, the ECM.
Fault Codes
or Incorrect
Aftertreatment Exhaust
Section TF -
16-t05- Gas Temperature 3 - Updated condition in Guided Step
24-Aug-2011 Troubleshooting
1878 Data Erratic, Intermittent, 2C.
Fault Codes
or Incorrect
Section TF - Aftertreatment Doser
16-t05- Added Guided Step 3F for check of
24-Aug-2011 Troubleshooting Circuit - Current Below
1977 pin-to-pin short on RETURN pin.
Fault Codes Normal or Open Circuit
Exhaust Gas
Recirculation Valve
Section TF - Differential Pressure - Changed the name of the title for
30-Aug-2011 Troubleshooting 16-fc2359 Data Valid But Above Fault Code 2359 from delta pressure
Fault Codes Normal Operating Range to differential pressure.
- Moderately Severe
Level
Exhaust Gas
Recirculation Valve
Section TF - Differential Pressure - Changed the name of the title for
16-t05-
30-Aug-2011 Troubleshooting Data Valid But Above Fault Code 2359 from delta pressure
fc2359
Fault Codes Normal Operating Range to differential pressure.
- Moderately Severe
Level
Aftertreatment Doser -
Section TF - Data Valid But Below
30-Aug-2011 Troubleshooting 16-fc3167 Normal Operating Range Added to manual.
Fault Codes - Moderately Severe
Level
Aftertreatment Doser -
Section TF - Data Valid But Below
16-t05-
07-Sep-2011 Troubleshooting Normal Operating Range Added to manual.
3167
Fault Codes - Moderately Severe
Level
Aftertreatment 1 Diesel
Oxidation Catalyst
Section TF -
System - Data Valid But
07-Sep-2011 Troubleshooting 16-fc4214 Added to manual.
Below Normal Operating
Fault Codes
Range - Moderately
Severe Level
Aftertreatment 1 Diesel
Oxidation Catalyst
Section TF -
16-t05- System - Data Valid But
07-Sep-2011 Troubleshooting Added to manual.
4214 Below Normal Operating
Fault Codes
Range - Moderately
Severe Level
Aftertreatment Diesel
Section TF -
Oxidation Catalyst
16-Sep-2011 Troubleshooting 16-fc4282 Added to manual.
Conversion Efficiency -
Fault Codes
Condition Exists
Aftertreatment Diesel
Section TF -
16-t05- Oxidation Catalyst
16-Sep-2011 Troubleshooting Added to manual.
4282 Conversion Efficiency -
Fault Codes
Condition Exists

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 32 of 37

Aftertreatment Doser -
Section TF -
Data Valid But Below
16-Sep-2011 Troubleshooting 16-fc4283 Added to manual.
Normal Operating Range
Fault Codes
- Condition Exists
Aftertreatment Doser -
Section TF -
16-t05- Data Valid But Below
16-Sep-2011 Troubleshooting Added to manual.
4283 Normal Operating Range
Fault Codes
- Condition Exists
Intake Manifold 1
Section TF - Pressure - Data Valid but Added a stuck in range exhaust gas
07-Oct-2011 Troubleshooting 16-fc125 Below Normal Operating pressure sensor as a possible root
Fault Codes Range - Moderately cause for this fault code.
Severe Level
Turbocharger Turbine
Intake Temperature
Section TF - Added a stuck in range exhaust gas
(Calculated) - Data Valid
07-Oct-2011 Troubleshooting 16-fc2346 pressure sensor as a possible root
But Above Normal
Fault Codes cause for this fault code.
Operating Range - Least
Severe Level
EGR Valve Control
Section TF - Added a stuck in range exhaust gas
Circuit - Voltage Below
07-Oct-2011 Troubleshooting 16-fc2451 pressure sensor as a possible root
Normal, or Shorted to
Fault Codes cause for this fault code.
Low Source
Water-In-Fuel Indicator -
Section TF - Data Valid But Above
12-Oct-2011 Troubleshooting 16-fc418 Normal Operational Updated Shop Talk
Fault Codes Range - Least Severe
Level
Guided Step 1A, YES, added: If Fault
Code 2448 is active and the coolant
Coolant Level - Data
Section TF - level is not low, a malfunctioning
16-t05- Valid But Below Normal
17-Oct-2011 Troubleshooting coolant level sensor is a likely cause.
2448 Operational Range -
Fault Codes Refer to the OEM service manual
Least Severe Level
before replacing the coolant level
sensor.
Section TF -
16-t05- Catalyst Efficiency - Out
19-Oct-2011 Troubleshooting Add Guided Step 4B.
2638 of Calibration
Fault Codes
Fuel Pump Delivery
Section TF - Pressure - Data Valid But A Note has been added to the Shop
7-Oct-2011 Troubleshooting 16-fc2215 Below Normal Operating Talk section to mention the hot
Fault Codes Range - Moderately start/stall orifice as a possible cause.
Severe Level
Section TS - Lubricating or
4021560- Revised turbocharger bearing
25-Oct-2011 Troubleshooting Transmission Oil in the
t108-tr housing is cracked or porous step
Symptoms Coolant
Section TF - EGR Valve Control
16-t05- Added check for Fault Code 2636
25-Oct-2011 Troubleshooting Circuit - Abnormal
1893 also being active
Fault Codes Update Rate
Turbocharger Use the following troubleshooting
Compressor Outlet symptom tree for information to
Section TF - Temperature continue to troubleshoot for low boost
16-t05-
23-Nov-2011 Troubleshooting (Calculated) - Data Valid pressure in the appropriate Service
2347
Fault Codes But Above Normal Manual . Reference the Intake
Operating Range - Least manifold Pressure (Boost) is Below
Severe Level Normal in Section TS.
Section TF - SAE J1939 Multiplexing
Updated the tree to reflect the
09-Dec-2011 Troubleshooting 00-t05-286 Configuration Error - Out
diagnostic operation.
Fault Codes of Calibration
Section TF - Crankcase Pressure - Changed step 1C to check that the
16-t05-
08-Dec-2011 Troubleshooting Data Erratic, Intermittent, cranckcase breather element is
1942
Fault Codes or Incorrect installed correctly.

Intake Manifold 1

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 33 of 37

Pressure - Data Valid But


Section TF -
Below Normal Added two refer to statements to
15-Dec-2011 Troubleshooting 16-t05-125
Operational Range - Guided Step 3A, YES.
Fault Codes
Moderately Severe Level
Guided Step 3B, NO, added: A pin-
to-pin short circuit in the
aftertreatment diesel oxidation
catalyst inlet temperature sensor
SIGNAL wire has been detected in
the harness, troubleshoot the OEM
harness, aftertreatment harness, and
Aftertreatment Exhaust all interconnects. Repair or replace
Section TF - Gas Temperature 1 the damaged harness and/or
16-t05-
15-Dec-2011 Troubleshooting Circuit - Voltage Below interconnects. Guided Step 3C, No,
1665
Fault Codes Normal or Shorted to added: A pin-to-ground short circuit in
Low Source the aftertreatment diesel oxidation
catalyst inlet temperature sensor
SIGNAL wire has been detected in
the harness, troubleshoot the OEM
harness, aftertreatment harness, and
all interconnects. Repair or replace
the damaged harness and/or
interconnects.
Guided Step 3B and 3C, NO, added:
Aftertreatment Exhaust
Section TF - A pin-to-pin short circuit in the
16-t05- Gas Temperature 1 -
15-Dec-2011 Troubleshooting aftertreatment diesel oxidation
1667 Data Erratic, Intermittent,
Fault Codes catalyst inlet temperature sensor
or Incorrect
SIGNAL wire has been detected.
Aftertreatment Exhaust Guided Step 3B and 3C, NO, added:
Section TF - Gas Temperature 2 A pin-to-pin short circuit in the
16-t05-
15-Dec-2011 Troubleshooting Circuit - Voltage Below aftertreatment diesel particulate filter
1674
Fault Codes Normal, or Shorted to inlet temperature sensor SIGNAL
Low Source wire has been detected.
Guided Step 3B, NO, added: An
open circuit in the aftertreatment
diesel particulate filter inlet
temperature sensor RETURN wire
has been detected. Guided Step 3B-
Aftertreatment Exhaust
1, NO, added: An open circuit in the
Section TF - Gas Temperature 2
16-t05- aftertreatment diesel particulate filter
15-Dec-2011 Troubleshooting Circuit - Voltage Above
1675 inlet temperature sensor SIGNAL
Fault Codes Normal, or Shorted to
wire has been detected. Guided Step
High Source
3C, NO, added: A pin-to-pin short
circuit in the aftertreatment diesel
particulate filter inlet temperature
sensor SIGNAL wire has been
detected.
Guided Step 3B and 3C, NO, added:
A pin-to-pin short circuit in the
aftertreatment diesel particulate filter
Aftertreatment Exhaust inlet temperature sensor SIGNAL
Section TF -
16-t05- Gas Temperature 2 - wire has been detected. Guided Step
15-Dec-2011 Troubleshooting
1676 Data Erratic, Intermittent, 3C, NO, added: A pin-to-ground short
Fault Codes
or Incorrect circuit in the aftertreatment diesel
particulate filter inlet temperature
sensor SIGNAL wire has been
detected.
Guided Step 3B, NO, added: An
open circuit in the aftertreatment
diesel particulate filter outlet
Section TF - temperature sensor RETURN wire
16-t05-
15-Dec-2011 Troubleshooting has been detected. Guided Step 3B-
1876
Fault Codes Aftertreatment Exhaust 1, NO, added: An open circuit in the
Gas Temperature 3 aftertreatment diesel particulate filter
Circuit - Voltage Above outlet temperature sensor SIGNAL
Normal or Shorted to wire has been detected. Guided Step

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 34 of 37

High Source 3C, NO, added: A pin-to-pin short


circuit in the aftertreatment diesel
particulate filter outlet temperature
sensor SIGNAL wire has been
detected.
Guided Step 3B, NO, added: A pin-
to-pin short circuit in the
aftertreatment diesel particulate filter
Aftertreatment Exhaust
outlet temperature sensor SIGNAL
Section TF - Gas Temperature 3
16-t05- wire has been detected. Guided Step
15-Dec-2011 Troubleshooting Circuit - Voltage Below
1877 3C, NO, added: A pin-to-ground short
Fault Codes Normal, or Shorted to
circuit in the aftertreatment diesel
Low Source
particulate filter outlet temperature
sensor SIGNAL wire has been
detected.
Guided Steps 3B and 3C, NO,
Aftertreatment Exhaust
Section TF - added: A pin-to-ground short circuit in
16-t05- Gas Temperature 3 -
15-Dec-2011 Troubleshooting the aftertreatment diesel particulate
1878 Data Erratic, Intermittent,
Fault Codes filter outlet temperature sensor
or Incorrect
SIGNAL wire has been detected.
Section TF - VGT Actuator Controller -
16-t05- Revised Step 1B to clarify the
20-Dec-2011 Troubleshooting Bad Intelligent Device or
2634 process to check the VGT actuator.
Fault Codes Component
Aftertreatment
Revised Guided Step 5A, NO: For
Particulate Filter
Section TF - ISX CM871 clean, inspect, and repair
16-t05- Differential Pressure -
6-Jan-2012 Troubleshooting the turbocharger assembly for reuse.
1981 Data Valid But Above
Fault Codes For ISM CM876 replace the
Normal Operating Range
turbocharger assembly.
- Least Severe Level
Guided Step 3A, change NO to:
Section TF - Aftertreatment Replace the aftertreatment diesel
16-t05-
24-Jan-2012 Troubleshooting Particulate Filter Missing particulate filter differential pressure
1993
Fault Codes - Condition Exists sensor. Refer to Procedure 019-443
in Section 19.
Section TF - Revised Guided Steps 1A and added
16-t05- Catalyst Missing -
30-Jan-2012 Troubleshooting Step 1B Check for inactive fault
1664 Condition Exists
Fault Codes codes.
Section 19 - Updated to include information
Electronic 105-019- concerning troubleshooting of ECM
10-Feb-2012 ECM Calibration Code
Engine Controls 032 calibration issues once new
- Group 19 calibration is installed..
Aftertreatment Fuel
Section TF - Removed Step 3 (3A, 3B, 3C, 3D,
16-t05- Injection System - Data
15-Feb-2012 Troubleshooting 3E, and 3F) for ISX (CM871) and
1932 Erratic, Intermittent, or
Fault Codes ISM (CM876).
Incorrect
Crankcase Pressure - Added note to Step 3A Conditions: It
Section TF -
Data Valid But Above may be necessary to disable the fault
30-Mar-2012 Troubleshooting 16-t05-556
Normal Operating Range code in order to operate the engine at
Fault Codes
- Most Severe Level rated speed.
Aftertreatment Doser -
Section TF - Data Valid But Below Added Step 2A - Perform the
16-t05-
02-Apr-2012 Troubleshooting Normal Operating Range Aftertreatment Maintenance Reset All
3167
Fault Codes - Moderately Severe procedure.
Level
Aftertreatment Doser -
Section TF - Added Step 2A - Perform the
16-t05- Data Valid But Below
03-Apr-2012 Troubleshooting Aftertreatment Maintenance Reset All
4283 Normal Operating Range
Fault Codes procedure.
- Condition Exists
Electrical Charging
Section TF - System Voltage - Data Changed Battery Voltage Monitor to
09-Apr-2012 Troubleshooting 16-fc596 Valid But Above Normal Alternator Failure Warning in Shop
Fault Codes Operating Range - Talk.
Moderately Severe Level
Electrical Charging

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 35 of 37

System Voltage - Data


Section TF - Changed Battery Voltage Monitor to
Valid But Below Normal
09-Apr-2012 Troubleshooting 16-fc597 Alternator Failure Warning in Shop
Operating Range -
Fault Codes Talk.
Moderately Severe Level
Electrical Charging
Section TF - System Voltage - Data Changed Battery Voltage Monitor to
09-Apr-2012 Troubleshooting 16-fc598 Valid But Below Normal Alternator Failure Warning in Shop
Fault Codes Operating Range - Most Talk.
Severe Level
Section TF - This fault code overview was
Catalyst Efficiency - Out
15-May-2012 Troubleshooting 16-fc1691 modified to accommodate both ISX
of Calibration
Fault Codes CM871 and ISM CM876.
Section TF - This troubleshooting fault code was
16-t05- Catalyst Efficiency - Out
15-May-2012 Troubleshooting modified to accommodate both ISX
1691 of Calibration
Fault Codes CM871 and ISM CM876.
Section TF - This troubleshooting fault code was
16-t05- Catalyst Face Plugged -
15-May-2012 Troubleshooting modified to improve diagnostic
2637 Root Cause Not Known
Fault Codes processes related to this fault code.
Section TF - This troubleshooting fault code was
16-t05- Catalyst Efficiency - Out
15-May-2012 Troubleshooting modified to improve diagnostic
2638 of Calibration
Fault Codes processes related to this fault code.
Aftertreatment 1 Diesel
Oxidation Catalyst
Section TF - This troubleshooting fault code was
16-t05- System - Data Valid But
15-May-2012 Troubleshooting modified to improve diagnostic
4214 Below Normal Operating
Fault Codes processes related to this fault code.
Range - Moderately
Severe Level
Aftertreatment Diesel
Section TF - This troubleshooting fault code was
16-t05- Oxidation Catalyst
15-May-2012 Troubleshooting modified to improve diagnostic
4282 Conversion Efficiency -
Fault Codes processes related to this fault code.
Condition Exists
Exhaust Back Pressure -
Section TF - Data Valid But Below
15-Jun-2012 Troubleshooting 16-fc2319 Normal Operating Range Added fault code to the manual.
Fault Codes - Moderately Severe
Level
Engine Brake Actuator
Section TF - Driver Output 2 Circuit -
16-t05-
06-Jun-2012 Troubleshooting Voltage Below Normal, Omitted: Check for a short to ground.
2363-ism
Fault Codes or Shorted to Low
Source
Engine Brake Actuator
Section TF - Driver Output 3 Circuit -
16-t05-
12-Jun-2012 Troubleshooting Voltage Below Normal, Omitted: Check for a short to ground.
2365
Fault Codes or Shorted to Low
Source
Section TF - Fan Control Circuit - Changed Step 2B Specifications:
01-Jun-2012 Troubleshooting 16-t05-245 Voltage Below Normal or Within the OEM resistance
Fault Codes Shorted to Low Source specification?
Changes: modification of Step 1A to
Section TF - prevent loop between 2638 and 1691
16-t05- Catalyst Efficiency - Out
25-Jun-2012 Troubleshooting and addition of Step 2D Clean the
2638 of Calibration
Fault Codes aftertreatment diesel oxidation
catalyst.
VGT Actuator Driver
Section TF - Circuit (Motor) - Updated Step 3A to include
16-t05-
05-Jul-2012 Troubleshooting Mechanical System Not instruction to use Snap Acceleration
2387
Fault Codes Responding Properly or – Aftertreatment Connected Test.
Out of Adjustment

Section TF - Exhaust Gas Changed: Conditions for Setting the


07-Jul-2012 Troubleshooting 16-fc2961 Recirculation Fault Codes, The engine control
Fault Codes Temperature - Data Valid module detects that the exhaust gas
But Above Normal recirculation temperature is greater

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 36 of 37

Operating Range - Least than 140°C [284°F] for more than 5


Severe Level seconds.
Exhaust Gas
Recirculation (EGR)
Section TF - Revised Guided Step 3C and added
16-t05- Valve Differential
07-Oct-2012 Troubleshooting Guided Step 3D for checking EGR
2359 Pressure - Data Valid But
Fault Codes valve.
Above Normal Operating
Range
Exhaust Gas
Section TF -
16-t05- Recirculation Valve Delta Revised text to include reference to
09-Sep-2012 Troubleshooting
1866 Pressure - Data Erratic, shellac plugging in Step 2B.
Fault Codes
Intermittent, or Incorrect
Exhaust Gas
Recirculation Valve Delta
Section TF -
16-t05- Pressure - Data Valid But Revised text to include reference to
09-Sep-2012 Troubleshooting
1899 Below Normal Operating shellac plugging in Step 2B.
Fault Codes
Range - Moderately
Severe Level
VGT Actuator Driver
Revised Shop Talk statement:
Section TF - Circuit (Motor) -
Inspect the turbocharger vanes for
03-Oct-2012 Troubleshooting 16-fc2387 Mechanical System Not
residue, and clean the vanes (if
Fault Codes Responding Properly or
required). Find the source and repair.
Out of Adjustment
Engine VGT Nozzle Revised Shop Talk statement:
Section TF -
Position - Mechanical Inspect the turbocharger vanes for
03-Oct-2012 Troubleshooting 16-fc3616
System Not Responding residue, and clean the vanes (if
Fault Codes
or Out of Adjustment required). Find the source and repair.
Aftertreatment Exhaust Has been re-written to help reduce
Section TF -
16-t05- Gas Temperature 1 - the high occurrence of aftertreatment
04-Feb-2013 Troubleshooting
1667 Data Erratic, Intermittent, exhaust gas temperature sensors
Fault Codes
or Incorrect being replaced in error.
Section 19 -
Procedure was revised to be brought
Electronic Aftertreatment Exhaust
04-Feb-2013 16-019-449 in line with the revised
Engine Controls Gas Temperature Sensor
troubleshooting steps in 16-t05-1667.
- Group 19
Intake Manifold 1 Added a check for plumbing
Section TF - Pressure - Data Valid But connections between the charge-air
25-Feb-2013 Troubleshooting 16-t05-125 Below Normal Operating cooler and air commpressorhead for
Fault Codes Range - Moderately leaks and inspect intake manifold
Severe Level gasket for leaks.
Exhaust Gas
Guided Step 3D, Condition: Added,
Recirculation (EGR)
TF - Connect the EGR differential
16-t05- Valve Differential
15-Mar-2013 Troubleshooting pressure sensor engine harness. And
2359 Pressure - Data Valid But
Faule Codes removed: Start the engine and operte
Above Normal Operating
to high idle.
Range
Section TT -
Engine Performance
Troubleshooting 16-t02- Added "Perform Timing Actuator
27-Mar-2013 Troubleshooting Tree -
Symptoms (New 1001a Flow Test" to Guided Step 5.
ISX with CM871
Format)
Section TF -
16-t05- Catalyst Efficiency - Out Corrected the 'Yes" block in Step 6C.
04-Apr-2013 Troubleshooting
1691 of Calibration No repair is required here.
Fault Codes
VGT Actuator Driver Updated to include a turbocharger
Section TF - Circuit (Motor) - sector gear teeth and sector gear
16-t05-
14-Apr-2013 Troubleshooting Mechanical System Not movement check after damaged
2387
Fault Codes Responding Properly or variable geometry turbocharger
Out of Adjustment actuator teeth are found.
Sectopm TT - Engine Performance Removed from Step 6E a malfunction
16-t02-
15-Apr-2013 Troubleshooting Troubleshooting Tree - cause statement naming debris
1001a
Symptoms ISX with CM871 exiting the engine as the source.
16-t02- Added a note to Step 6E: Inspect the
15-Apr-2013 Sectopm TT - Engine Performance
1001b turbocharger shaft movement.
Troubleshooting Troubleshooting Tree -

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17
Manual Change History Page 37 of 37

Symptoms ISM with CM876


The torque value used to install the
Section 19 -
EGR Temperature exhaust gas temperatuare sensor
9-May-2013 Electronic 16-019-378
Sensor has been changed from 57 n.m [42-
Engine controls
ft-lb] to 34 n.m [25 ft-lb].
Intake Manifold 1
Section TF - Pressure - Data ValidBut
Added air intake and exhaust
24-Jun-2013 Troubleshooting 16-t05-125 Below Normal Operating
restriction.
Fault Codes Range - Moderately
Severe
Section TF - SAE J1939 Multiplexing Updated Action, to determine which
02-Jul-2013 Troubleshooting 00-t05-286 Configuration Error - Out multiplexed component is causing the
Fault Codes of Calibration fault
BACK TO TOP

Last Modified: 08-Jul-2013

Copyright © 2000-2010 Cummins Inc. All rights reserved.

mk:@MSITStore:R:\MR_D.CHM::/english/manual/4021560/4021560-history.html 5.12.17

Вам также может понравиться