Академический Документы
Профессиональный Документы
Культура Документы
REFLECTION
GROUP 3
Tanakom Kaweewuthisinp
Nichaporn Nattawut
Witchayut Ngarmpornchai
Phatsakorn Rodphol
Accelerated Physics
Mahidol University International
Demonstration School
Semester 1 Academic year 2017-2018
ANALYSIS
The rocket did not launch well
because the pressure was leaking
out of the bottle. Thus when we
launch the rocket, the pressure
go out and the rocket cannot fly.
When the pressure has been given into the rocket, it
leaks through the hole which is occured because we cut
the bottle on the both end and we didn’t seal it back well
enough. So the pressure can leak out and the rocket
could not be launched.
1. Analyze your rocket's motion:
- How long was your rocket in the air? 0.1 sec
- Estimate your rocket's maximum height. Show and explain all
calculations.
The rocket was launched with small amount of pressure as
pressure was leaking out. Therefore, our rocket flew only 0.05
meter above the ground level before it is dropped to the ground.
Y = vt -1/2gt*t
Y = 0 - ½ * -10 * 0.1*0.1
Y = 0.05 m
- What was your rocket's maximum velocity? Show and explain
all calculations.
The maximum velocity is when the rocker was launched with
pressure from the launching point.
Y = ut + 1/2 g t*t
0.05 = 0.1u + ½*-10*0.1*0.1
U = 1 m/s
6. How do you feel about this project now that it has concluded?
I feel that we have fail the assignment because our rocket didn’t
performance well. It didn’t goes as height as other groups rocket.
However, we still think that this project is fun and interesting. We
learn a lot from this failure and we think that if we have a chance
to do it again it will be better.
7. What would you have done differently as you and your team
worked through this project?
If we have a chance to do this project again we will find more
information in terms of rocket creation. We will plan the rocket
better because this model did not performance well due to the
pressure is leaking out of the bottle.