Академический Документы
Профессиональный Документы
Культура Документы
DATE :11/12/2017
TIME :12:00-1:00pm
ATTENDANCE : FULL
MEETING AGENDA:
1. Reading through both of the assignment questions. While highlighting the main points and the
problem stated.
2. Focusing on solving Question 1 first.
It is consisted of 3 sub questions (a), (b) and (c).
Rewriting and listing all given information to ease further calculations.
3. For question (a) to calculate the developed pump head;
Need to find internal diameter based on appendix 3 (textbook)
The viscosity and density of C2H4O based on Perry’s Chemical Engineer Handbook
Obtained value of friction factor (f) from figure 1.
Using Perry’s Chemical Engineer Handbook Table 6-5 (Additional Friction Loss For
Turbulent Flow Through Fittings and Valves)
4. Each member drafting their own answer for Question 1 while discussing with each other.
5. Comparing results to see if the methods used were similar or not and to see whether the answer
is correct.
If the answer was roughly similar but with using a different method then discuss the
reasons as to why it is so.
MINUTES OF MEETING
DATE :12/12/2017
TIME :7pm-8pm
ATTENDANCE : FULL
MEETING AGENDA: