Академический Документы
Профессиональный Документы
Культура Документы
A Campbell diagram chart result is only valid in Modal analyses. The Campbell
diagram chart result is mainly used in rotor dynamics for rotating structural
component design. When a structural component is rotating, an inertial force is
introduced into the system. The dynamic characteristics of the structural component
change as a result of the inertia effect, namely, gyroscopic effect. To study changes
in dynamic characteristics of a rotating structure, more than one solve point
in Rotational Velocity is required.
Prerequisites
In addition to being applicable to only Modal analyses, you must ensure that the
following Analysis Settings are activated in order to properly apply a Campbell
Diagram. Select the Analysis Settings object in your Modal Analysis and perform
the following settings:
To insert a Campbell diagram chart result, highlight the Solution object in the tree,
then select Campbell Diagram from the Solution Context Toolbar, or right click on
the object and choose Insert>Campbell Diagram.
In addition to whirl modes, a line (black color) of any ratio between whirl frequency
and rotational velocity is plotted. The intersection between this line and each whirl
mode is indicated with a red triangular marker. The rotational velocity corresponding
to this intersection is called critical speed. At critical speed, the rotating structural
component will experience a peak as the rotating frequency resonates with the
natural whirl frequency.
Scope
Rotational Velocity Selection: This field displays the user-defined
Rotational Velocity of the analysis for which the Campbell diagram chart result
is evaluated. If one is not defined, the field is highlighted in yellow and
displays the value None.
Campbell Diagram Controls
Y Axis Data: The data type options
include: Frequency (default), Stability, Logarithmic Decrement,
and Modal Damping Ratio.
Critical Speed: Option for users to display critical speeds. The default
is Yes. Requires you to provide a value in the Ratio field. The option is only
valid for frequency.
Ratio: Value used to evaluate critical speeds. The default value is 1.0.
Sorting: Option to display data in a sorted mode manner when some modes
are crossing/intercepting each other. The default is Yes.
Axis
Note: Two different unit types, rad/s and RPM, are available to define rotational
velocity in the chart. The selection can be made in Units toolbar.