requirements Measures Hold the 1) Mount shield Jet skis are known for rattling Previous knowledge in the Rubber dries The bolt rattle shield in via bolts to bolts out of the engine even marine water craft field. out causing can be solved place the main with locking nuts and lock- shrinkage and with the use of body tight. Rattling the shield can thus space Ny lock nuts 2) Mount the induce cracks in the shield and between the and or lock tight shield via can also reduce visibility in two to prevent back rivets to the components. out. main body This would be 3) Mount with hard to fix if The rubber any of the rivets are used. problem can be above with The bolts can solved with the rubber also rattle use of outdoor spacers loose thus also uv resistant between the causing space rubber. main body in fitment. and the shield to help prevent rattling Resist 1) Use a Material options and design Manufacturing Systems Ununiform Check to see if deflection material that both contribute to the strength composites uniform when forces can withstand of the part. Plastics and metals can have composites are from wind is the torque on can be changed from the random weak possible in this applied to the the system original state with the addition points that will case and use the shield. 2) Use of additives. Polymers can be affect the bulk best material for reinforcement changed into composites with properties the application in the added fibers that will help material to carry the loads. The chosen Find a material enhance material might that can properties react badly withstand the 3) Add with high heat 140-degree reinforcement thus causing Fahrenheit sun ribs to fitment heat enhance the problems. torque capacity of Changing the Design the ribs the design can around the component. cause fitment current design problems where they are needed based on stress analysis. Be 1) Paint it to Better looks increases the Previous knowledge Changing the Design a clip-on aesthetically match probability of use. Otherwise design might façade that will pleasing 2) Design add if produced it wont sell. Paint affect strength be used to create ons to it to will also seal the material the illusion of match flow from any possible oxidation. Chipping paint smooth of the can hurt rider aerodynamics. aerodynamics while riding of the ski Apply a good 3) Appear as a Stock looks base coat, clear stock item to can cause and wax to the ski others to be maintain paint jealous of you quality. on the water Give them your phone number if they want to buy one from you.
Main Body in 1060 Aluminum: Max
stress is approx. 24MPa Main Body in Rigid PVC Plastic Main Body in ABS Plastic