Академический Документы
Профессиональный Документы
Культура Документы
2. Ensure that a valid engine serial number is programmed into the ECM. The clearing
process will not work without a valid programmed serial number. Navigate to Winflash,
Click on Utilities, and choose “Clear ECM Memory”
3. ECM Clearing will only work on Non-Factory installed ECMs. If you are unsure if
your ECM is factory installed, click “Yes” and verify in the FPS screen that appears.
Otherwise click “No” to continue with the ECM Clearing. You may also want to record
the engine serial number and previously loaded flashfile in case of an issue during
clearing.
4. Load the proper ECM Clearing file in Winflash and flash the ECM. Do not interrupt
power during the clearing process or the ECM may become corrupted.
5. Return to Cat ET
6. The ECM Clearing Screen in Cat ET will appear. Click “Clear Memory” on the lower
left hand side.
8. You will then be prompted for a Factory Password. Follow your standard procedure
for obtaining passwords.
10. Disconnect from Cat ET. The ECM is now cleared and can be used for another
application. A default interlock code of 43690 has been programmed into the ECM. Be
sure to mark this ECM in some fashion to alert other users that this is a cleared ECM and
will require additional setup.
Part II – Set Up Cleared ECM (TC or Technician)
11. In order to use this ECM for another application, you must reconnect to the ECM
with Cat ET. When you reconnect, click the “Winflash” button.
14. The “Personality Module Mismatch” box appears. Click “Cancel” to continue
setting up the ECM for the new application.
15. Navigate to the “Configuration” screen in Cat ET and program the correct “Engine
Serial Number” for the new application.
16. You must then disconnect and then reconnect to the ECM with Cat ET.
17. The “Personality Module Mismatch” box appears again. This time click “OK”.
18. Click “OK” on the next “Personality Module Mismatch” box that appears as well,
after verifying the new engine serial number is displayed.
19. You will then be prompted for another Factory Password. Follow your standard
procedure for obtaining passwords.
20. Once you have entered the Factory Password the process is complete. The ECM has
now been successfully cleared, reflashed, and had the serial number reprogrammed to the
appropriate new application.
Jim Snodgrass
o Phone: 1-800-447-4986 (TEEC)
o Email: Snodgrass_James_K@cat.com