Академический Документы
Профессиональный Документы
Культура Документы
SikaGard®-6440
Sprayable underbody / stone chip protection coating
SikaGard® -6440 1 / 2
Chemical Resistance Removal Value Basis
® ®
SikaGard -6440 is resistant Fresh SikaGard -6440 can be All technical data stated in this
against water, seawater, salt removed from tools and equipment Product Data Sheet is based on
®
spray, oil, bases and acids. with Sika Remover-208. Once laboratory tests. Actual measured
The above information is offered dried, the material can only be data may vary due to circum-
for general guidance only. Advice removed mechanically. stances beyond our control.
on specific applications will be Hands and exposed skin should be
®
given on request. washed immediately using Sika Health and Safety Information
Handclean towels or a suitable For information and advice regar-
Method of Application industrial hand cleaner and water. ding transportation, handling, stor-
Surface preparation Do not use solvents! age and disposal of chemical
Surfaces must be clean, dry and Over painting products, users shall refer to the
free of rust, dust and grease. Bare ® actual Safety Data Sheets contain-
SikaGard -6440 is over paintable
metal must be pre-treated to en- in a dry state (after 24 hours) with ing physical, ecological, toxicologi-
hance corrosion resistance (e.g. commonly used conventional paint cal and other safety-related data.
uncoated steel, etc). systems. Waiting time can be
reduced by accelerated drying at Legal Notes
Application
® max. 60°C. Due to the wide range The information, and, in particular, the
SikaGard -6440 can be applied by recommendations relating to the appli-
air-mix guns with an air pressure of of paints adhesion and compatibil-
cation and end-use of Sika products,
®
3 - 6 bar. Use either the Sika SCP ity tests are necessary.
are given in good faith based on Sika's
Gun (pressure cup type) or the current knowledge an experience of the
® Further Information
Sika UBC Gun (vacuum type) to products when properly stored, handled
apply the product. Copies of the following publication and applied under normal conditions in
Shake can approx. 40 times before is available on request: accordance with Sika's recommenda-
- Safety Data Sheet tions. In practice, the differences in
use. Cover adjacent surfaces prior
materials, substrates and actual site
the spray process. Spray at room conditions are such that no warranty in
temperature and from a distance of Packaging Information respect of merchantability or of fitness
approx. 25 cm in an X motion to Can 1l for a particular purpose, nor any liability
build up a continuous coat. arising out of any legal relationship
®
SikaGard -6440 can be applied whatsoever, can be inferred either from
without dripping. Apply this product this information, or from any written
until the desired layer thickness is recommendations, or from any other
advice offered. The user of the product
reached. If a thick layer is required,
must test the product’s suitability for the
let layers dry in between. A wide intended application and purpose. Sika
variety of textures can be achieved reserves the right to change the proper-
by altering the spray technique. Do ties of its products. The proprietary
not spray on parts of the brake, rights of third parties must be observed.
engine or exhaust system. All orders are accepted subject to our
current terms of sale and delivery.
Users must always refer to the most
recent issue of the local Product Data
Sheet for the product concerned, cop-
ies of which will be supplied on request.
Sika Limited
SikaGard® -6440 2 / 2