Академический Документы
Профессиональный Документы
Культура Документы
Q2. When a capacitor was connected to the terminal of ohmmeter, the pointer indicated a low
resistance initially and then slowly came to infinity position. This shows that capacitor is
(a) Short-circuited (b) all right (c) faulty (d) None of the
Ans: b
Q3.What device is used to measure the very high insulation resistance of electric cables?
Ans: C
Q4.in a balanced Wheatstone bridge, across the center of the bridge there is
a) No current flow b) No voltage is present at either end c) Current always flows in one
direction only d) Current and voltage are at a new maximum
Ans: a
Q5. When an AC current of 5A and dc current of 5A flow simultaneously through a circuit then
which of the following statement is true?
a) Two electrical devices will have the same combined resistance if they are connected in series
as they will have if connected in parallel
b) If one of three bulbs in a parallel lightening circuit is remove, the total resistance of the circuit
will become greater
c) An electrical device that has a high resistance will use more power than one with a low
resistance with the same applied voltage
d) A 50 Ohm resister in a 12 volt circuit will use less than a 10 Ohm resister in a 24 volt circuit
Q10. When a drawing is amended which does not affect interchangeability, the
The usual practice when a drawing is changed is to re-issue it with a new revision number.
All quality plans are controlled by management and the quality of the project is the
main responsibility of project managers.
Minor repairs and modifications not requiring extensive disassembly and which can be
accomplished by simple means is known as
C) Support decision-making
Ans: d
Quality control is focused on fulfilling quality requirements, whereas quality assurance is focused on
providing confidence that quality requirements are fulfilled.
A. PCM
B. PWM
C. Differential PCM
D. Delta
a) Ground waves (b) sky waves (c) surface waves (d) space waves.
Answer : D
A transistor will notconduct (that is, no current will flow through from the collector to the
emitter) unless there is a also potential difference between the emitter and the base of at least
0.6 V
Radio Horizon:The radio horizon for space waves is about four-thirds as far as the
optical horizon. This beneficial effect is caused by the varying density of the atmosphere,
and because of diffraction around the curvature of the earth. It is given with good
approximation, by the empirical formuladt=4 √htwhere dt= distance (in km) from the
transmitting antenna,ht = height (in m) of transmitting antenna above the groundThe
same formula applies to the receiving antenna.
Waveguide acts as a high pass filter in that most of the energy above a certain frequency (the
cutoff frequency) will pass through the waveguide, whereas most of the energy that is below the
cutoff frequency will be attenuated by the waveguide.
The voltage standing wave has the node and the current standing wave the anti node with
There is a voltage standing wave, as well as current standing wave. Both have exactly the
same shape, only that they are out of phase with each other to λ/4, ie at one's voltage
antinode, corresponds a current node of the other and vice versa.
The directional characteristics of combined vertical dipole and loop antenna arrangement is a
Directive gain is
Antenna gain is usually defined as the ratio of the power produced by the antenna from a far-
field source on the antenna's beam axis to the power produced by a hypothetical lossless
isotropic antenna, which is equally sensitive to signals from all directions.
(A) The phase velocity will increase. (B) The group velocity will increase. (C) The phase
velocity will decrease. (D) None
C. the lowest frequency by which communication is possible between two given points
Answer: Option B