Академический Документы
Профессиональный Документы
Культура Документы
Maintaining a properly functioning VSP G1000, VSP G1500, and VSP F1500 storage system includes having the proper
knowledge of troubleshooting issues when they occur and access to help with more technically complicated matters.
Child Topics
• Getting help
• Solving problems
The following table lists possible error conditions and recommends actions to resolve each condition for VSP
G1000, VSP G1500, and VSP F1500 storage systems.
• Service information messages
Getting help
If you continue experience technical difficulties after troubleshooting the storage system, contact Hitachi Vantara
Support at https://support.hds.com/en_us/contact-us.html.
Parent Topic
• Troubleshooting the storage system
Solving problems
The following table lists possible error conditions and recommends actions to resolve each condition for VSP G1000,
VSP G1500, and VSP F1500 storage systems.
If you cannot resolve an error condition, contact your Hitachi Vantara representative or contact customer support for
assistance.
Table 1: Troubleshooting errors
Determine the type of error (refer to the SIM codes section). If possible, fix the cause of
Error message displayed the error. If you cannot correct the error condition, contact customer support for
assistance.
https://knowledge.hds.com/Documents/Storage/VSP_G1X00_and_VSP_F1500/80-06-xx/Hardware_Guide/Troubleshooting_the_storage_
Updated: Sat, 21 Apr 2018 04:18:11 GMT
Powered by
1
Error condition Recommended action
Turn off all PDU switches and breakers. After the facility power is fully restored, turn on
the switches and breakers and power on the system.
Determine whether there is a failed storage path. If a failed storage path occurred,
Fence message is
toggle the RESTART switch and retry the operation. If the fence message displays
displayed on the console
again, contact customer support for assistance.
If there is a temperature problem in the area, turn the power off to the storage system,
lower the room temperature to the specified operating range, and then turn on the
ALARM LED is on power to the storage system. If necessary, contact customer support for assistance
with turning on the power to the storage system. If the area temperature is not the
cause of the alarm, contact customer support for assistance.
Parent Topic
• Troubleshooting the storage system
SIMs can be generated by the front-end directors, back-end directors, and the SVP. All SIMs generated by the storage
system are stored on the SVP for use by Hitachi Vantara personnel, displayed by the Device Manager - Storage
Navigator software, and reported over SNMP to the open-systems host. The SIM display on Storage Navigator enables
users to remotely view the SIMs reported by the attached storage systems. Each time a SIM is generated, the amber
https://knowledge.hds.com/Documents/Storage/VSP_G1X00_and_VSP_F1500/80-06-xx/Hardware_Guide/Troubleshooting_the_storage_
Updated: Sat, 21 Apr 2018 04:18:11 GMT
Powered by
2
Message LED on the control panel turns on. The Hi-Track® remote maintenance API also reports all SIMs to the
support center.
SIMs are classified in four severity levels: service, moderate, serious, and acute. The service and moderate SIMs
(lowest severity) do not require immediate attention and are addressed during routine maintenance. The serious and
acute SIMs (highest severity) are reported to the host system once every eight hours.
NoteIf a serious-level or high-level SIM is reported, contact the support center immediately to ensure the problem is
being addressed.
The following figure illustrates a typical 32-byte SIM from the storage system. The SIMs are displayed by reference code
(RC) and severity. The six-digit RC comprises bytes 22, 23, and 13, identifies the possible error and determines the
severity. The SIM type, located in byte 28, indicates which component experienced the error.
Figure 1: Service information message
Parent Topic
• Troubleshooting the storage system
https://knowledge.hds.com/Documents/Storage/VSP_G1X00_and_VSP_F1500/80-06-xx/Hardware_Guide/Troubleshooting_the_storage_
Updated: Sat, 21 Apr 2018 04:18:11 GMT
Powered by
3