Академический Документы
Профессиональный Документы
Культура Документы
Solutions containing a value are not accepted. Full mark is only at given time. Later
homeworks even minutes breaks the mark with respect to late time. Whatever late is; sent only the answers below to the instructor .by hand or email:
kdundar1954@gmail.com
A Aliminum B C
Steel
round bar
Q-1:Assuming that A and C are tension bars that dB
are connected by double shear bolts where AC is 3a
rigid bending beam to carry the weight at B
kN
as shown in the figure;
a- find the dimensions of steel round bar and square head including thickness at B :
dB=……. standart ……… mm □bB=……. mm tB=… …. mm
b- find the dimensions of Aliminum rectangular bar and steel bolts at A :
dA=……. standart ……… mm tA=… …. mm bA =……. mm
c- Select the lightest (minimum area) standart steel L shape and steel bolts at C:
L ……... x…………x……….. dC=……. standart ……… mm
d- find the slope angle “α” of AC caused by deflections of A and C : α= ……... °
Materials:
Steel: σall=180 N/mm² all= 0,577·σall E=200000 N/mm²
Aliminum: σall =70 N/mm² all= 0,577·σall E=70000 N/mm²
take standart diameters below for bolts and round bar although there exists others:
1,2,3,4,5,6,7,8,9,10,11,12,13,14,16,18,20,22,24,27,30,33,36,39,42,45,48,52,56,60,64,68,72 mm
F L F F V K Lshape 2 Mc M
tension average bending K bending
EA compression A shear A shear A K circle 1,33 I S
----------------------------------------------------------------------------------------------------------------------------- ---------------------------------------------------------------------------
HW-3 Find first center of gravity yG ; then moment of inertias (second moment) about Gx axis:
If you like After writing dimensions mm as below, change dimensions to cm for preventing huge inertias
_
y y=yG=……….
A B C D
100+a cm 50+a cm 50 cm
d-by taking care of C bolt hole at center; what is the larger bending stress on C
σC=+/-? .............. N/mm²
Materials:
Steel: σall=200 N/mm² all= 0,577·σall E=200000 N/mm²
Aliminum: σall =70 N/mm² all= 0,577·σall E=70000 N/mm²
take standart diameters below for bolts although there exists others(mm)
1,2,3,4,5,6,7,8,9,10,11,12,13,14,16,18,20,22,24,27,30,33,36,39,42,45,48,52,56,60,64,68,72
F L F F V K Lshape 2 Mc M
tension average bending K bending
EA compression A shear A shear A K circle 1,33 I S
----------------------------------------------------------------------------------------------------------------------------- ------------------------------------------------------------------------
HW-4:
100 All the crosssections of beams are equilateral triangle,
N having 35 mm base, 30 mm height and the material is
h= 30
brittle-casting, therefore find only positive bending
35 mm stresses:draw V, M diagrams for AD beam:
a N/cm